Toro 22319, Руководство оператора

Страница: 48 / 52

Problem Possible Cause Corrective Action
1. The key was turned to the start position
before the glow plug light turned off.
1. Turn the key to the run position and
allow the glow plug light to turn off
before starting the engine.
2. The engine temperature is low. 2. Check the thermostat.
3. The glow plugs are inoperative.
3. Check the fuse, glow plugs and wiring.
4. The injection pump timing is incorrect. 4. Contact your Authorized Service
Dealer.
5. The injection nozzles are damaged. 5. Contact your Authorized Service
Dealer.
Excessive white smoke from exhaust.
6. Low compression 6. Contact your Authorized Service
Dealer.
1. The engine load is excessive. 1. Reduce ground speed.
2. The crankcase oil level is incorrect. 2. Fill or drain to the full mark.
3. The air cleaner filters are dirty. 3. Service the air filters.
4. Dirt, water, stale fuel, or incorrect fuel
is in the fuel system.
4. Drain and flush the fuel system; add
fresh fuel.
5. Engine overheating. 5. Refer to Engine Overheats.
6. The spark arrestor screen is clogged. 6. Clean or replace the spark arrestor
screen.
7. There is air in the fuel. 7. Bleed the nozzles and check for air
leaks at fuel hose connections and
fittings between the fuel tank and
engine.
8. Low compression 8. Contact your Authorized Service
Dealer.
9. The fuel tank vent is restricted. 9. Contact your Authorized Service
Dealer.
10. The injection pump timing is incorrect.
10. Contact your Authorized Service
Dealer.
The engine loses power.
11. The injection pump is damaged. 11. Contact your Authorized Service
Dealer.
1. The parking brake is on. 1. Release the parking brake.
2. Hydraulic fluid level low. 2. Add hydraulic fluid to the reservoir.
3. The tow valves are open.
3. Close the tow valves.
4. Pump and/or wheel motor is damaged. 4. Contact your Authorized Service
Dealer.
Traction unit does not drive.
5. Relief valve is damaged. 5. Contact your Authorized Service
Dealer.
48