21
11. INSPECTION AND MAINTENANCE BEFORE RIDING
INSPECTION AND REPLENISHMENT OF ENGINE OIL
Inspection:
y
Turn the main switch to the “ON” position, if the
oil warning light comes on continuously, this
indicates the engine oil level is too low, add oil as
required.
y
Check oil tank and oil lines for leakage.
Replenishment:
1. Using the main stand to support the vehicle on a level ground, lift up the seat, and remove the oil tank
cover.
2. Turn the oil tank cap to the left to remove. Add oil until reaches to the standard level.
3. Screw in the oil tank cap until properly tightened, then reinstall the tank cover and lower the seat
and press it down until locked.
TRANSMISSION OIL INSPECTION AND CHANGE
INSPECTION:
y
Use the main stand to support the scooter on a level ground, after the engine stops, wait for 3~5
minutes. Remove the transmission oil infusion bolt, put a measuring glass under the drain bolt, and
remove the drain bolt. Let the oil flows into measuring glass and check for decreased or not. (at
disassembly: 120 c.c. / at change: 100~110 c.c.).
OIL REPLACEMENT:
y
Stop the engine and use the main stand to support
your scooter on a level ground. Remove the infusion
bolt and drain bolt, drain out the oil.
y
Install the drain bolt and tighten it. Fill new
transmission oil (100~110 c.c.), and install the infusion
bolt and tighten it. (make sure that bolts are tightened
and check that there’s no leakage.)
※
Recommend Oil: Genuine SYM HYPOID GEAR OIL
(SAE 85W-140).
Add oil note:
y
Use only 2-cycle engine oil meeting Japanese Automobile Standard Organization FC specifications.
SANYANG will not assume responsibility for damages caused from using substandard engine oil.
y
When adding oil, do not let foreign matter, such as dust, dirt, etc. to enter into the oil system.
Do not use different brands of mixed oil.
y
Do not add oil above the standard level. Clean spilled oil around the oil cap.
y
Be sure to properly tighten the oil cap after adding oil and before riding the scooter.
WARNING:
y
To continue ride the scooter under low oil level condition will result in an engine seizure due to lack
of lubrication of engine parts. It is therefore very important to bring your scooter to your dealer
for an
oil replenishment immediately whenever the warning light comes on continuously.
y
Use only 2-cycle engine oil meeting Japanese Automobile Standard Organization FC
specifications. Otherwise, this company will not assume any responsibility for damages resulted
from using substandard engine oil.
※
Recommended oil: SYM EXTRA 2X oil.
