Senci SC 8000D, Руководство пользователя, Страница: 64 / 68

GENERATOR MAINTENANCE
REGULAR MAINTENANCE To ensure the generator in good condition, regular inspection and maintenance is very important. Disconnect
the storage battery’s wire connected to the generator when maintenance, firstly disconnect negative pole wire, then positive pole wire.
If diesel generator must keep running when maintenance, make sure of the ventilation nearby. After using generator, wipe clean it’s
surface traces of oil and dirt with cloth to prevent corrosion.
8.1.1 CHANGE OIL REGULARLY Change oil after the first 20 hours or first month of operation, then every 50 hours. Change oil every 100
hours or three month after 3 times oil change. Twist off the oil level Gauge, unscrew the oil drain plug when diesel generator is still hot
to drain used oil(Drain plug is in the bottom of the cylinder block).Tighten the oil drain plug and add oil. 8.1.2 CLEAN THE OIL FILTER
Loosen the lock nut, take out the oil filter and wash it with a clean petrol or kerosene. 8.1.3 CLEAN AND CHANGE THE AIR FILTER
ELEMENT Do not clean the air filter element with cleaner.Brush off the outer dirt of the air filter element with a soft brush.
！
NOTICE: DO
NOT START THE DIESEL GENERATOR WITHOUT FILTER ELEMENT OR BREAKAGE. 8.1.4 Wash and change the fuel filter. Fuel filter must
wash frequently to ensure a maximum output power of diesel engine. (1) Discharge the fuel from fuel tank; (2) Loosen the small screw
of fuel switch,take out the filter and clean the filter thoroughly with diesel oil. 8.1.5 Tighten the cylinder head bolt
14
！
NOTICE: SPECIAL TOOLS WILL BE USED WHEN TIGHTEN THE CYLINDER HEAD SCREWS 8.1.6 Check the nozzle, high pressure pumps, etc.
8.1.7 Adjust the inlet and exhaust valve clearance. 8.1.8 Replace piston rings
！
NOTICE: DO NOT EXPOSE SKIN IN FUEL SPRAY WHEN
OPERATION. FUEL CAN PENETRATE SKIN AND CAUSE BODY HARM.KEEP AWAY FROM THE NOZZLE WHEN MEASUREING FUEL INJECTOR
ATOMIZATION SITUATION. 8.1.9 The GENERATOR use 12V storage battery. Check battery before start. Replace it if it is damaged. 8.2 THE
MAINTENANCE OF THE LONG TERM STORAGE If the generator will be stored for long time, the following operation must be conducted.
8.2.1 Run generator for 15 minutes, then stop it. 8.2.2 Discharge the oil when the generator is still hot, then add new oil to specified
height. 8.2.3 Unscrew out the oil plug on the cylinder head cover, and add 2ml lubricating oil, then tight the oil plug. 8.2.4 Maintenance
of start part (1) Recoil start Keep the fuel switch in the "OFF" position, press the reducing handle and don't loosen, pull the starting
handle 2-3 times (not start diesel generator). (2) Electrical start Keep the fuel switch in the “OFF” position, press the reducing handle and
turn starting key for 2-3 seconds, but don’t start the generator. 8.2.5 Pull out the reducing handle, pull out the recoil start slowly when
feel resistance. 8.2.6 Remove the storage battery from the generator in order to maintain monthly. To keep the battery voltage between
12-14V when storage, do not store the battery when the battery voltage is lower than 10.8V to avoid damage. 8.2.7 Clean the generator
and store it in a dry place.
Italia Star Com Due S.R.L.
www.italiastar.ro
info@italiastar.ro
004/021.433.03.27
64