A. GENERAL BATTERY SAFETY
. Before you use your battery charger, be sure to read all
instructions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or device using battery
2. Use battery charger on LEAD ACID type rechargeable
batteries only, such as used in autos, trucks, tractors, airplanes,
vans, RVs, trolling motors, etc. Charger is not intended to
supply power to low-voltage electrical system other than in
an automotive application.
WARNING:
Do not use battery charger for charging dry-cell
batteries that are commonly used with home appliances. These
batteries may burst and cause injury to persons and damage
to property.
3. Use only attachments recommended or sold by manufacturer.
Use of non-recommended attachments may result in fire,
electric shock, or injury.
4. When disconnecting the battery charger, pull by the plug not
by the cord. Pulling on the cord may cause damage to cord or
plug.
5. Locate battery power cord so it cannot be stepped on, tripped
over, or subjected to damage or stress.
6. Do not operate charger with damaged cord or plug. Have cord
replaced immediately.
7. Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a
qualified professional for inspection and repair.
8. Do not disassemble charger. Take it to a qualified professional
when service or repair is required. Incorrect reassembly may
result in electric shock or fire.
9. To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
0. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or electric
shock. If an extension cord must be used, make sure that:
• Pins on plug of extension cord are the same number, size,
and shape as those of the plug on the charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
Length of cord (feet):
25
50
100 150
AWG size of cord:
16
14
10 8
(American Wire Gauge)
. Always charge battery in a well ventilated area.
NEVER
operate in a closed-in or restricted area without
adequate ventilation because of risk of explosive gases.
WARNING:
Risk of explosive gas.
2. Locate charger as far away from battery as DC charger cables
permit.
3. Do not expose charger to rain or snow.
4.
NEVER
charge a frozen battery. If battery fluid (electrolyte) is
frozen, bring into a warm area to thaw before charging.
5.
NEVER
allow battery acid to drip on charger when reading
specific gravity or filling battery.
6.
NEVER
set a battery on top of charger.
7.
NEVER
place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
8.
NEVER
touch the battery clips together when the charger is
energized.
00-99-000625/006
SCHUMACHER ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
In United States: Send Warranty Product Repairs to: 025 E. Thompson, Hoopeston, IL 60942-0280
Call Customer Service if you have questions: -800-62-5485
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal battery
operation. For this reason, it is of utmost importance that each time before using your charger, you read this manual
and follow the instructions exactly.
Owner's Manual
–Save–
Important Safety Instructions
WARNING:
Handling the cord on this product or cords associated with accessories sold with this product, may expose you to lead, a
chemical known to the State of California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling
.
™
Battery
Charger
Model:
SE-40225 Manual Battery Charger
2 Amp, 12 Volt
20 Amp, 12 Volt
40 Amp, 6 & 12 Volt
225 Amp, 12 Volt, Engine Start
125 Amp, 6 Volt, Engine Start
