KBox C-103-CFL-x - User Guide, Rev. 1.0
// 75
10.4.
Cleaning the Air Filter
The air filter is inserted in the holder (Figure 32, pos. 2) at the bottom side of the fan tray slot (Figure 32, pos. 6). The
soiling of the air filter (Figure 32, pos. 3) is caused by the pollution of the operating environment. A heavily soiled air
filter can cause excessive heating of the device. For this reason we recommend to clean the air filter as often as
necessary. The air filter can be changed during operation of the system.
Figure 57: Fan tray extension (detail: shown as KBox C-103-CFL-1)
To replace the air filter, proceed as follows:
1.
Ensure to have access to the bottom side of the KBox C-103-CFL-4/-2/-1. The air filter may be replaced without
removing the fan tray (Figure 57, pos. 1).
2.
Loosen the knurled screw (Figure 57, pos. 3) that secures the air filter holder (Figure 57, pos. 4) to the fan tray
slot (Figure 57, pos. 5); refer to step 1 in Figure 57.
3.
Pull the air filter holder out of the positioning holes, (Figure 58, pos. 9) into the marked direction (see Figure 57)
and pull it down. Put the air filter holder aside for later reassembly; refer to step 2 and 3 in Figure 57.
4.
Remove the soiled air filter (Figure 57, pos. 3 and Figure 58, pos. 6).
5.
Clean the air filter as follows:
6.
Rinse in water (up to approx. 40°C; possibly with the addition of a standard mild detergent).
7.
It is possible to clean the air filter with compressed air.
8.
For dirt that contains grease/oil, the air filter should be rinsed with warm water with the addition of a degreaser.
Air filter should not be cleaned with powerful water jets or wrung out.
9.
After cleaning and drying the air filter, place it in the air filter holder.
10.
Reattach the air filter holder to the bottom side of the fan tray slot by inserting the positioning latches
(Figure 58, pos. 8) into the positioning holes (Figure 58, pos. 9).
11.
Secure the air filter holder by tightening the knurled screw to the tapped hole (Figure 58, pos. 4) of the fan tray
slot
(Figure 57, pos. 5 or Figure 58, pos. 3).
Defective components may only be replaced by Kontron original spare parts.
Air filter: part number: 9-5000-1099 (for KBox C-103-CFL-4)
Air filter: part number: 9-5000-1098 (for KBox C-103-CFL-2)
Air filter: part number: 9-5000-1097 (for KBox C-103-CFL-1)
1 Fan tray
2 Knurled screws of the fan tray
3 Knurled screw of the air filter
holder
4 Air filter holder
5 Fan tray slot
3
2
1
4
5
3
1
2
2
Содержание Kontron KBox C-103-0
Страница 2: ...KBox C 103 CFL x User Guide Rev 1 0 www kontron com 2 This page has been intentionally left blank...
Страница 28: ...KBox C 103 CFL x User Guide Rev 1 0 www kontron com 28 Figure 12 Block Diagram KBox C 103 CFL x...
Страница 124: ...KBox C 103 CFL x User Guide Rev 1 0 www kontron com 124...
