11
P/N 1011263 Rev. C 12/15
Replacing Belts (Quarterly)
Over time, the Belts will begin to show signs
of wear (tearing or discoloration of the belt)
at which point the belts should be replaced.
NOTE:
Belts should be removed ONLY
during Belt Replacement or when
required in a service situation.
For proper operation, replace all
belts at the same time.
NOTE:
All Belts MUST be replaced every
90 days.
Removing Belts
1. Turn the toaster’s power switch to
the off position. The toaster enters a
cool-down mode and will automati-
cally shut down when complete.
2. Unplug the power cord once the
cool-down period is complete.
3. Put on neoprene gloves. Remove the
optional Top Feeder (if present) and
remove the Bun Feeder.
4. Remove the Front and Rear Con-
veyor Covers by lifting up and away
from the toaster.
5. Set the Compression Knob to 7.
Unlock the latch and open the left
side panel.
6. To lock the front Conveyor Roller,
face the front of the toaster. Use both
hands and push down on the Front
Conveyor Roller and pull towards
you. This removes tension and locks
the roller in place (Figure 11).
7. To lock the Rear Roller, face the rear
of the toaster. Use both hands and
push down on the Rear Conveyor
Roller and pull towards you. This
removes tension and locks the roller
in place (Figure 11).
8. Lift the upper Belt Frame Lock. Then
rotate down so it rests on the cam
shaft of the rear conveyor roller.
(Figure 12).
9. Pull down the lower Belt Frame Lock
(Figure 12).
10. Remove and discard the Front Belt
(the recommendation is to cut it in
half so it cannot be used again). See
Figure 13.
11. Remove and discard the Rear Belts
(the recommendation is to cut them
in half so they cannot be used again).
See Figure 13.
12. Wipe all four rollers with a clean tow-
el sprayed with sanitizer. Make sure
to remove all debris from the rollers
so they are as clean as possible.
TENSE
TENSE
LOOSE
LOOSE
Figure 11. Conveyor Rollers
Figure 12. Conveyor Locks
Figure 13. Remove and Discard the Belts
DO NOT REUSE THE BELTS!
LOWER BELT FRAME
LOCK
UPPER BELT FRAME
LOCK
CROWN BELT
WRAP
CLUB/HEEL
BELT WRAP
CROWN
BELT WRAP
MAIN
BELT WRAP
Содержание 9210880
