Roberts Gorden VANTAGE HEV-100, Инструкция по установке, эксплуатации и обслуживанию

Страница: 3 / 80

© 2021
Roberts-Gordon LLC
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon LLC.
TABLE OF CONTENTS
SECTION 1: Heater Safety ...................................................... 1
1.1 Manpower Requirements ............................................. 1
1.2 Safety Labels and Their Placement.............................. 1
1.3 California Proposition 65 .............................................. 1
SECTION 2: Installer Responsibility......................................4
2.1 Wall Tag ....................................................................... 4
2.2 Corrosive Chemicals.................................................... 4
2.3 National Standards and Applicable Codes...................4
SECTION 3: Clearances to Combustibles.............................5
3.1 Required Clearances to Combustibles......................... 5
SECTION 4: National Standards and Applicable Codes...... 9
4.1 Gas Codes................................................................... 9
4.2 Aircraft Hangars ........................................................... 9
4.3 Public Garages ............................................................9
4.4 Electrical ......................................................................9
4.5 Venting......................................................................... 9
4.6 High Altitude ................................................................ 9
SECTION 5: Major Components .......................................... 10
5.1 Standard Parts List .................................................... 12
SECTION 6: Heater Installation............................................ 15
6.1 Outdoor Mounting...................................................... 17
SECTION 7: Optional Heater Accessories .......................... 27
7.1 U-Tube Configuration.................................................. 27
7.2 Elbow Package Configuration..................................... 31
7.3 Reflector Side Extension (Not for outdoor use
or areas exposed to wind)........................................... 33
7.4 Lower Clearance Shield Installation ........................... 34
7.5 Two-Foot Decorative Grille Installation ....................... 34
7.6 Protective Grille Installation ........................................ 36
SECTION 8: Venting .............................................................. 38
8.1 General Venting Requirements.................................. 38
8.2 Unvented Operation................................................... 38
8.3 Horizontal Venting...................................................... 39
8.4 Vertical Venting ..........................................................39
8.5 Unvented Operation Tube Termination....................... 39
8.6 Length Requirements ................................................ 39
8.7 Venting Options..........................................................41
8.8 Horizontal Ventilation 4" (10 cm) Pipe........................ 41
8.9 Vertical Ventilation 4" (10 cm) Pipe ............................ 42
8.11 Common Vertical Venting ........................................ 43
8.12 Outside Combustion Air Supply ...............................44
SECTION 9: Gas Piping ........................................................ 46
SECTION 10: Wiring .............................................................. 48
10.1 Line Voltage Thermostat Wiring ...............................48
10.2 Low Voltage Thermostat with One Burner ............... 48
10.3 Low Voltage Thermostat Wiring with
Multiple Burners ...................................................... 49
10.4 Internal Wiring.......................................................... 49
10.5 Ladder Diagram....................................................... 50
10.6 Electrical Connection to the Burner Box using Line
Voltage Thermostat on Control ........................................ 50
10.7 Electrical Connection to Burner Box using
Low Voltage Thermostat on Control......................... 51
SECTION 11: Operation and Maintenance.......................... 52
11.1 Sequence of Operation ............................................ 52
11.2 To Shut Off Heater .................................................... 52
11.3 To Start Heater ......................................................... 52
11.4 Pre-Season Maintenance and Annual Inspection..... 52
11.5 Maintenance Checklist ............................................. 53
SECTION 12: Troubleshooting ............................................. 55
12.1 Troubleshooting Flow Chart ..................................... 56
12.2 Manifold Gas Pressure Setting ................................ 58
SECTION 13: Replacement Parts ........................................ 59
SECTION 14: General Specifications .................................. 61
14.1 Material Specifications............................................. 61
14.2 Heater Specifications............................................... 61
14.3 Suspension Specifications....................................... 61
14.4 Controls Specifications ............................................ 61
SECTION 15: The ROBERTS GORDON
®
VANTAGE
®
HEV
Warranty.......................................................... 62
Printed in U.S.A.