2
3
We recommend that you look at our website to see the latest
updated the operating instructions.
Instructions for use Bioclear XL 40000
Carefully read the operating instructions before using this filter for the first
time. It is important that you know both the safety regulations and the use
of this filter. It should be noted that people who did not sit
into the operating instructions should not work with the filter.
As we continuously improve and develop our products, accessories etc.
differ from the pictures on the packaging.
Symbols
Inlet from the pump to the filter
Outlet from the filter to the pond
Rewind the filter
Unpacking
If you see damage to the filter or accessories when unpacking,
you should notify your dealer immediately.
Safety regulations
Never use the pressure filter if the cable, UV-C lamp or filter container is damaged. Never
open the UV-C housing or its parts unless it is written in these operating instructions.
Check that the type plate of the appliance corresponds to your local voltage. The pressure
filter must always be connected across a ground fault circuit interrupter of max. 30 mA.
Make sure that electrical outlets and contacts are always dry.
If you have any doubts or questions regarding the electrical connections, consult an
authorized electrician.
Interventions intended to manipulate or change the filter's electronics pose a danger.
If such interventions are made, all warranty is void.
Never lift or carry the filter in the power cord. Protect it from heat, oil and sharp edges.
Position the cable so that it is not damaged.
The appliance must not be used by children or by others whose physical or mental
knowledge is not sufficient to use the appliance.
The pressure filter must never be immersed in water.
Never use the pressure filter if there are people in the pond.
Pumps with a larger capacity than those recommended by the filter manufacturer must not
be used. The filter MUST be cleaned regularly. It must never work with a water pressure
higher than 0.2 Bar = 2 meters lifting height. A higher working pressure in the filter can
cause O-rings to not hold tightly and consequential damage occurs such as. that the dam
is emptied of water.
The maximum pressure capacity of the pump must not exceed 0.5 Bar (5 meters lifting
height).
Only use hoses that are approved for a pressure of at least 0.2 Bar. The height difference
between the filter cover and the highest point of the outlet hose may be a maximum of 1 m.
Check and, if necessary, clean the filter outlet to the dam regularly. The outlet must always
be free so that the filter does not risk being exposed to a pressure higher than 0.2 Bar. This
can cause the filter to start leaking and emptying the dust.
During all work on the pressure filter and the UV-C unit, the current must always be cut off
by pulling the electrical plug out of the socket.
Technical data
Model: 40000
Filter volume:
170 liter
Max. pond size without fish:
40.000 liter
Max. pond size with little fish:
20.000 liter
Max. pond size with lots of fish/koi: 10.000 liter
Max. pump capacity:
15.000 l/t
Inlet / outlet:
40/50 mm
UV HQ2 PL:
55 watt
Volt:
230V 50 Hz
Connection with external thread
2”
Size (LxBxH):
60x60x85 cm
English
The box contains
1
bioclear pressure filter with UV
3x2 hose connections 40/50 mm hose
2 unions
3 flat packs
1 drain tap with universal hose connection and union
1 instructions for use
Use
Bioclear with built-in UV-C is a biological and mechanical pressure filter intended for
cleaning garden ponds with or without fish. It is for private use only.
