7
Perlick.is.committed.to.continuous.improvement..Therefore,.we.reserve.the.right.to.change.specifications.without.prior.notice.
START.UP.PROCEDURES
Priming The Chemical Pumps
Place.the.chemical,.detergent,.chlorine,..
and.rinse.aid.containers.in.a.convenient..
location..Place.appropriate.drop.tube.into..
corresponding.container.as.labeled.on.the.drop.
tube.
■
Red.Line......... Detergent.Container
■
White.Line....... Sanitizer.Container
■
Blue.Line......... Rinse.Aid
Press.and.hold.detergent.prime.button..
Window.will.illuminate.so.that.chemical.flow.
can.be.observed..When.chemical.is.observed,.
hold.for.an.additional.15.seconds..This.will.
allow.the.chemical.to.reach.the.wash.tank.
area..Repeat.procedure.for.Sanitizer.and.
Rinse.Aid.
Setting The Chemical Controls
1. ChEMICAL SwITCh
.
This.switch.turns.the.chemical.pump.system..
.
on.and.off.and.will.be.used.to.delime.the..
.
machine..The.switch.should.be.in.the.
.
ON.position.
2. dETERgENT CONTROL
.
Controls.detergent.concentration.with.. .
.
three.pre-calibrated.settings:
.
.
1.=.Lowest.Concentration
.
.
2.=.Medium.Concentration
.
.
3.=.Highest.Concentration
Your.water.hardness,.detergent.strength.and.
amount.of.water.conditioners.in.the.detergent.will.
determine.the.final.setting.of.this.control..Start.
with.the.control.on.No..1.and.increase.until.the.
best.cleaning.result.is.achieved.
3. SANITIZER CONTROL
.
Controls.chlorine.concentration.with.an.
.
infinite.adjustment..This.control.is.set.so..
.
that.a.minimum.of.50.ppm..of.chlorine.is..
.
obtained..Use.the.chlorine.test.kit.to.set..
.
this.control.provided.with.the.glasswasher...
.
NOTE:.This.setting.should.be.tested.daily..
.
and.must.be.adjusted.according.to.local..
.
health.standards.
4. RINSE AId
.
Controls.rinse.aid.concentration.with.three..
.
pre-calibrated.settings:
.
.
1.=.Lowest.Concentration
.
.
2.=.Medium.Concentration
.
.
3.=.Highest.Concentration
Your.water.hardness.and.the.strength.of.the.rinse.
aid.used.will.determine.the.final.setting.of.this.
control..Start.with.the.control.in.the.No..1.position..
If.the.water.does.not.sheet.on.the.glassware,.and.
droplets.are.present,.increase.the.concentration..
