INSTALLER: PLEASE LEAVE THESE
INSTALLATION INSTRUCTIONS WITH
THE HOMEOWNER
7087060
(Replaces 7086340)
the drain pan and cause a condensate
leak.
2. Connect the drain line and run to a suitable
drain avoiding sharp bends and pinching of
the line. Install a condensate trap and prime
with water.
3. During the system checkout, inspect the
drain line and connections to verify proper
condensate disposal.
Air Filter —
Air filters are not provided as an
integral part of this coil, however, a filter must
be installed upstream of the coil and inspected
frequently. When the filter becomes clogged with
dust or lint, it should be replaced (disposable type)
or cleaned (washable type). The filter should be
inspected and replaced or cleaned at least twice
during the year, generally at the start of each
heating and cooling season.
Close-Off Plates and Panels —
Install the
necessary air close-off plates around the
refrigerant lines and drain line where required.
Reinstall all inner and outer panels of the coil
case and furnace that were previously removed
to install the indoor coil.
Refrigerant Charging —
These cased indoor
coils are not factory charged with refrigerant.
It will be necessary to evacuate the indoor coil
and line set prior to charging. Refer to the outdoor
unit installation manual for detailed charges and
instructions.
7. MAINTENANCE AND SERVICE
WARNING:
Ensure that all electrical power to the
furnace and outdoor (condensing)
unit is off before performing any
maintenance or service on the
system.
To ensure optimum performance and to minimize
possible equipment failure, the following periodic
maintenance should be performed on this
equipment:
1. The air filter installed with the system should
be checked and cleaned or replaced twice
per year.
2. Check the coil, drain pan, and condensate
drain line for cleanliness at the start of
each heating and cooling season. Clean
as needed.
CAUTION:
Do not operate the system without
having a suitable filter in place in
the return air duct system. Always
replace the filter with the same size
and type.
Specifications & illustrations subject to change
without notice or incurring obligations (05/15).
O’Fallon, MO, © Nortek Global HVAC LLC 2015.
All Rights Reserved.
