OPERATION
Concorde
HP Plus (01–00)
5
MACHINE INSTALLATION
UNCRATING MACHINE
Carefully check carton for signs of damage. Report
damages at once to carrier.
Check carton contents list below. Contact your
distributor for missing items.
1 – Recovery Dome (stored in battery
compartment)
1 – Recovery Dome Vacuum Hose (stored in
recovery tank)
1 – Battery Tray
2 – Battery Cables (stored in battery
compartment)
1 – Pumpout Hose (stored in recovery tank)
1 – Standpipe Screen (stored in recovery tank)
1 – Solution Tank Fill Port Strainer (stored in
recovery tank)
1 – Spray Bar (installed on machine)
1 – Battery Charger (Included with Concorde
HP Plus Pac 608935) Packaged Separately
3 – 12V Batteries (Included with Concorde
HP
Plus Pac 608935; not included with Pac
609256) Packaged Separately
ATTENTION: Battery installation must be
accomplished after removing machine from
shipping crate.
ATTENTION: DO NOT roll machine off pallet or
use a forklift, machine damage will occur. Use a
hoist or ramp.
INSTALLING BATTERIES
WARNING: Batteries emit hydrogen gas.
Explosion or fire can result. Keep sparks and
open flame away. Keep battery compartment open
when charging.
FOR SAFETY: When servicing machine, wear
protective gloves when handling batteries or
battery cables. Avoid contact with battery acid.
Battery Specifications:
Three 12 volt, 215 Ah, deep cycle batteries. Consult
with an Authorized Distributor for specific batteries.
Maximum battery dimensions are 178mm(7in)W x
380mm(15 in)L x 370mm(14.63 in)H.
1.
Before installing batteries pull out the main circuit
breaker button to shut off power to machine.
Circuit breaker panel is located at rear lower right
of machine (Figure 1).
FOR SAFETY: Before leaving or servicing
machine, stop on level surface, turn off machine
and pull out main circuit breaker button.
FIG. 1
2.
Lift battery compartment hood off machine and
remove loose battery cables.
3. Carefully install batteries into battery tray with
negative posts towards back of machine.
(Figure 2).
ATTENTION: Be careful not to drop batteries into
compartment, battery and machine housing
damage may result.
FIG. 2
