G Series Gas Grills
LTR50001050, Rev. M
Using Y
our
Grill
www.calflamebbq.com
15
Each time you light the grill, check the following:
• Inspect the hose before using the grill. If there is
excessive abrasion or wear, or if the hose is cut,
it must be replaced prior to using the grill. See
page 8 for LP connection instructions and specifi-
cations. If you need a replacement hose, contact
your Cal Flame dealer.
• Ensure the area around the barbecue is clear of
flammable substances such as gasoline, yard de-
bris, wood, etc.
• Ensure there is no blockage of the airflow through
the vent space located below the face of the unit.
• When using propane gas, keep the special venti-
lation openings in the enclosure free and clear of
debris.
• If connected to a propane cylinder, carefully in-
spect the rubber hose attached to the regulator
before each use.
• Ensure the propane cylinder, regulator, and rubber
hose are installed in a location not subject to heat-
ing above 125º F (51º C).
• Ensure the burner flames burn evenly along both
sides of each burner with a steady flame (mostly
blue with yellow tipping). If burner flames are not
normal, check the orifice and burner for insects or
insect nests.
• Ensure the in-line gas valve or gas cylinder valve
is always shut OFF when the barbecue is not in
use.
• Do not operate the side burner with its cover
closed or the back burner with its cover installed.
Lighting the Burners
Electronically Lighting the Burners
1. Open the hood.
2. Keep your face as far away from the burners as
possible.
3. Press and rotate the burner knob counter
clockwise past the light position to HIGH. You
will hear a loud click as the electronic lighter
produces a spark.
4. Listen for the sound of the gas igniting. If the
burner does not light on the first try, repeat
immediately.
5. If the burner does not light after three attempts,
turn the control knobs to the OFF position. Wait
five minutes until the gas clears before attempting
to light it again.
6. Repeat the procedure or try the manual lighting
procedure below.
7. Upon successful lighting, repeat the process on
the other burners you wish to light.
8. To shut off the burners, rotate the knob and turn
to OFF. It is normal to hear a popping sound
when the burners are turned off.
Grill Controls
4
3
Burners
2
1
Grill Knob Operaon
Low
Off
High
The controls shown below are for the G4 grill. Familiarize yourself
with these controls before using your Cal Flame™ barbecue.
