34
Safety
2.
Activate arms ‘down’. The arms should not move.
3.
If the arms move, refer to “Adjusting Body Raised Proximity Switch (Tip-to-Dump Units)” on
page 85.
Test: Tailgate Function Locked Out by Body Raised
On full eject units with a service hoist or on tip to dump units, the body triggers a proximity switch
when it is down and at rest on the chassis frame. When this proximity switch is not activated, it locks
out the tailgate ‘open’ and ‘close’ functions. This lockout prevents the operator from having the
tailgate contact refuse and other debris on the ground or during ejection.
For this test, proceed as follows:
1.
Raise the body off the chassis frame.
2.
Activate the tailgate ‘open’ function. The tailgate should not move.
3.
Activate the tailgate ‘close’ function. Again, the tailgate should not move.
4.
Test: Hoist Locked Out by Arms Not Stowed
Referring to tip to dump units only, the arms trigger a proximity switch when they are raised fully and
contact the body bumper pads. The forks also trigger a proximity switch when they are raised fully.
When both of these proximity switches are activated (as in when the forks are stowed in the hopper),
the body hoist will not function. This lockout prevents damage to the chassis cab.
For this test, proceed as follows:
1.
With the arms down, activate the hoist ‘up’ function.
2.
The hoist should not function.
3.
N
OTE
:
Backwards arms must be stowed to raise body.
Caution!
Be careful not to cause damage to the cab when performing this test.
Caution!
Be careful not to cause damage to the tailgate when performing this test.
Содержание Pendpac WITTKE RETRO FL
