PROBLEM
PROBABLE CAUSE
SOLUTION
Pasta Cooker has poor recovery or
runs cold.
a.Over-filling baskets.
b.Thermostat out of calibration.
c. Element is faulty.
d.Thermostat is faulty.
e.Contactor is faulty.
a.Don’t overfill baskets.
b.Calibrate thermostat. See pages
9-10 - Calibration.
c. Replace element.
d.Replace thermostat.
e.Replace contactor.
Contactor chatters.
a.Voltage is low to Pasta Cooker.
b.Contactor coil faulty.
c. Connections are loose.
d.Thermostat contacts do not close
properly.
a.Contact your electrician or the
local power company and have
the incoming power checked.
b.Replace contactor.
c. Tighten connections.
d.Replace thermostat.
Basket-Lift mechanism does not
operate.
a.Connections are loose or timer is
faulty.
b.Motor limit switch is faulty.
c. Lift motor is faulty.
d.Actuator is faulty.
e.Control circuit fuse has blown.
f. Relay is faulty.
a.Tighten connections. Replace
timer if it will not operate.
b.Replace limit switch.
c. Replace motor. Specify left or
right side when ordering.
d.Replace actuator.
e.Replace fuse.
f. Replace relay.
Basket-Lift motor runs, but basket
doesn’t move.
a.Cam is slipping on the motor
shaft.
a.Tighten cam onto motor shaft.
Basket-Lift basket goes down, but
won’t go up.
a.Basket-Lift motor limit switch is
misaligned.
a.Align limit switch.
Basket-Lift buzzer won’t shut off.
a.Buzzer limit switch is misaligned.
a.Align limit switch.
12
COMMON PROBLEMS
SOLUTIONS (FOLLOW IN SEQUENCE)
Unit is out of power
1. Check electrical connection.
2. Check fuses.
3. Check Hi-Limit control.
Содержание INSTANT RECOVERY SERIES 2009
