![background image](http://html1.mh-extra.com/html/jayco/jay-flight-2023/jay-flight-2023_owners-manual_3623333091.webp)
85
Section 7: Fuel & Propane System
ASME tanks are permanently mounted to the RV and are commonly used on RV mo-
torhomes. The capacity of ASME tanks is expressed in gallons. ASME tanks are filled
while the tank is attached to the motorhome by a qualified propane facility. ASME tanks
are equipped with an automatic stop fill valve designed to reduce the potential of overfilling.
ASME propane tanks are also equipped with a P.O.L. service valve that is for connection of
the supply hose with a left hand threaded brass P.O.L. fitting from the tank service valve to
the two-stage regulator. Not for use on gas grills and other low pressure devices.
NOTE: Tanks are to be installed, fueled and maintained in accordance to
State and Local codes, rules, regulations or laws.
Propane is a true gas compressed into a liquid form. As the fuel is released from the con-
tainer, it changes to vapor which is then used for the operation of the appliances. Propane
will not run through the appliances in the liquid state.
Propane expands 1½ percent for every ten degrees of increase in temperature. It is impera-
tive to leave sufficient space inside the container to allow for natural expansion of gas during
warmer weather.
The main shut off valve must be kept closed at all times unless
you are using the propane system or filling the propane cylinder.
When the cylinder is disconnected from the hose, install the valve
cover that is attached to the container.
Close the propane cylinder main shut off valve by
hand tightening
only. Use of tools createto over tighten the valve (damaging the
interior seals on the cylinder valve seat). If this type of damage
occurs, the cylinder will not close properly.
This propane label should be kept permanently affixed to your
RV.
Servicing or Filling
Have the recreation vehicle checked for leaks at the connections on the propane system soon
after the purchase and the initial filling of each propane cylinder.
When you have a new cylinder filled for the first time, make sure your propane supplier
purges your new cylinder of trapped air. Otherwise, an improper mixture of gas and air will
make it impossible to light your propane appliances.
No one should be inside the RV and only the qualified
propane service technician should be near the RV while
the propane tank is being filled. The new propane con
-
tainer must be carefully purged for best performance
and must
NEVER BE OVERFILLED
. This “shut off
for re-fueling” label should be kept permanently affixed
to your RV.
The position of the propane container(s) and the hos-
es are critical to proper operation and propane flow.
Follow these instructions to make sure your propane
container(s) are connected properly.
LP Gas Container Overfill
Never allow your propane tank to be filled above the maximum safe level as indicated by the
fixed liquid level gauge. Do not allow the visible gauge to be used for filling. Overfilling the
propane container above the liquid capacity indicated on the container, could allow liquid
propane to enter the system that is designed for vapor only creating a hazardous condition.
“Use propane only” Label
(Canada only)
Table of Contents
Содержание JAY FLIGHT 2023
