Jacobsen Cushman Turf Truckster, Руководство по запасным частям и обслуживанию

Страница: 34 / 210

5 MAINTENANCE
en-34
5.32 STORAGE________________________________________________________________
General
1. Wash the vehicle thoroughly and lubricate as
necessary. Repair and paint damaged or exposed
metal.
2. Inspect the vehicle, tighten all hardware, replace
worn or damaged components.
3. Drain and refill radiator.
4. Clean the tires thoroughly and store the vehicle so
the load is off the tires. If vehicle is not on jack
stands check tires at regular intervals and reinflate
as necessary.
5. Keep the machine and all its accessories clean, dry
and protected from the elements during storage.
Battery
1. Remove, clean and store battery in upright position
on a nonconductive surface (wood) in a cool, dry
place. To prevent accelerated discharge do not store
battery on concrete or steel surface.
2. Check and recharge battery every 60 to 90 days
while in storage.
3. To reduce the self discharge rate room temperature
should not rise above 80°F (27°C). Room
temperature should not fall below 20°F (-7°C) to
prevent electrolyte from freezing.
Engine (General)
1. While the engine is warm remove the drain plug,
drain the oil from the crankcase, and change oil filter.
Install drain plug and refill with fresh oil. Let engine
cool before storing.
2. Clean exterior of engine. Paint exposed metal or
apply a light coat of rust preventative oil.
Add a fuel conditioner or biocide to prevent gelling or
bacterial growth in fuel. See your local fuel supplier.
If storing indoors drain fuel from tank.
Close fuel shut off valve.
After Storage
1. Check and reinstall battery.
2. Check or service fuel filter and air cleaner.
3. Check the radiator coolant level.
4. Check oil level in the engine crankcase.
5. Fill the fuel tank with fresh fuel. Open fuel shut off
valve and bleed the fuel system.
6. Make certain that the tires are properly inflated.
7. Start and operate the engine at 1/2 throttle. Allow
sufficient time for the engine to become properly
warmed and lubricated.
WARNING
Never store equipment near an open flame or spark
which could ignite fuel or fuel vapors.
!
WARNING
Never operate the engine without proper ventilation.
Exhaust fumes can be fatal when inhaled.
!