ICETEAM 1927 COMPACTA VARIO US, Инструкция по эксплуатации

Страница: 53 / 54

Compacta VariO US
- 53 -
Compacta VariO US - 2018/05 - Rev. 01
EN
Possible causes
a) Main switch
open
b) Plug connecting to the
mains disconnected
c) The machine is not in
production mode both in
freezing section
and in cooking section.
d) Spigot doors not perfectly
closed.
a) Third phase, supplying
compressor and electric
motors, is missing.
a) Water-cooled machine:
water is not circulating.
b) Air-cooled machine: air is
not circulating.
a) No gas in the machine
b) Faulty pressure switch
a) No sugar in the mix
a) Too much sugar in the
mix
a) Seal missing or worn out
8. TROUBLESHOOTING
Recommended remedies
a) Turn switch off
b) Check and turn on.
c) Check that PRODUCTION
button is on.
d) Check that spigot doors are
closed
a) Connect the 3
rd
phase or
check for any blown fuses.
a) Open the shut-off valve
of condensate water.
Make sure the rubber pipe
is not squashed or bent.
b) Make sure the rear side of the
machine has a distance of at
least cm 50 from the wall.
Remove any rags, dust,
etc. from condenser.
Check operation of fan
motor.
a) Check for leak
weld and recharge
b) Check the connection and
replace it
if necessary
a) Wait for the ice-cream in
the cylinder to melt, then
modify or change the mix.
a) Modify or change the mix
a) Install it if missing
Replace it if worn out.
Problems
The machine will not start
The machine will not start
(display on)
Compressor starts and
then stops after a few seconds,
but the ice cream has not
reached the right consistency.
After 15 minutes of
freezing cycle the mix does not
freeze: the machine switches to
STOP mode
The machine is working but no
ice cream is dispensed by the
spigot door
The machine is working but
the ice cream is too soft
Mix flowing into tray