Hyundai DHY6000LR, Руководство пользователя

Страница: 21 / 32

8. LONG TERM STORAGE
• After running the engine the oil will be very hot.
•
Wear correct PPE minimum of gloves and
overalls.
8.1. If storing the generator for long periods of time, make the following operations.
8.1.1. Operate the engine for 10 minutes and then stop.
8.1.2. Stop the engine.
8.1.3. Drain the engine oil whilst the engine is still warm and refill with fresh oil.
8.1.4. Turn the engine for 2-3 seconds with the decompression lever set at the non-
compression position and the starting key set at the 'START' position. (Do not start the
engine.)
8.1.5. Wipe off the oil and dirt from the engine and store in a dry place.
9. TROUBLESHOOTING.
9.1. Troubleshooting - N.B. all corrective actions should be carried out by suitably qualified
person/s.
Problem Possible fault/cause Remedy
The Diesel engine will not
start
The governer lever is not at
START position
Set lever to START position
Emergency STOP button
activated (depressed)
Re-set emergency STOP
button
Insufficient fuel Refill with fuel
Fuel injection pump does not
deliver fuel or delivers
insufficient fuel
Remove the injector pump
and have it tested
Check the engine oil level
The specified oil level should
be to the upper lever
The injector has severe carbon
build-up
Clean the injector
The start motor turns slowly
Check battery performance
and all connections
The battery is flat
Charge or replace with a new
one
The generator is not
producing power
Main breaker switch has not
been turned ON
Turn the main breaker to the
ON position
Alternator brushes worn Replace the brushes
The contact in the socket is
not good
Make sure plugs are fully
inserted into sockets
The rated sped is too HIGH or
too LOW
Adjust engine speed to
produce 52 Hz with no load
AVR is damaged Replace AVR
Page 21 Rev 3