Cleaning Prep:
Close the water supply line shut-off valve and
dispense all the ice from the storage bin.
Move the
power switch
to
OFF
. Remove the
Louver
& Air Filter
.
Move the
control switch
to
DRAIN
.
Move the
power switch
to
ON
. Allow the icemaker to drain
completely. Move the
power switch
to
OFF
.
ATTENTION! WAIT 1 MINUTE AFTER POWERING OFF,
to allow control board to de-energize. Otherwise there will
be a long delay before ICE or DRAIN will activate.
Cleaning:
Unplug
the icemaker from the electrical outlet. Dilute Hoshizaki Scale
Away with warm water (see Table below). Remove the
Front Panel*
,
Top Panel
,
Bin Top
,
Agitator
,
Drip Ring, Grille,
and
Spouts A & B**.
Pour cleaning solution over the
Extruding Head
until
the
Evaporator Assembly
and the
Reservoir
are full
and the solution overflows into the
Drain Pan
. Allow
to soak for
10 minutes
.
*
Push-button models: Take care in disconnecting the button connector.
**
Use a 15mm socket with an extension to easily remove recessed thumb screws.
In bad water conditions, a more thorough soaking may be
required. Follow Step
, then place a clamp on the
Reservoir
hose that will block the flow to the
evaporator
assembly
. Pour additional cleaning solution over the
Extruding Head
until the
Evaporator Assembly
is full.
Allow to soak. Otherwise, continue to Step
.
DCM-270BAH(-OS)
Scale Away
6 fl. oz (177 ml)
Warm Water
1 gal. (3.8 l)
Reservoir Hose
Control Switch
Power Switch
Ice Machine
DCM-270BAH(-OS)
Sanitizing:
x
Dilute 5.25% chlorine
bleach
‡
with warm water
(see Table below)
DCM-270BAH(-OS)
Bleach
1.5 fl. oz (44 ml)
Warm Water
3 gal. (11.4 l)
‡
Use bleach without additives.
x
Pour the sanitizing solution
over the extruding head until
solution starts to overflow
into the drain pan
x
Allow to soak for 10 minutes
x
Scrub all items with a nylon
scouring pan, brushes, and
sanitizing solution
x
Rinse all items thoroughly
with clean water
x
Move
control switch
to ICE,
replace the front panel
x
Reassemble drip ring, agitator,
bin top, grille, spouts A & B,
and replace panels
x
Plug in the icemaker
x
Move the
power switch
to ON
x
Make ice with the solution until
it stops, dispose of ice
x
Move the
power switch
to
OFF
x
Unplug the icemaker
Allow
to
drain
Cleaning & Sanitizing
AMMONIA
Cleaners
The icemaker/dispenser must be cleaned & sanitized at least twice a year.
1
continued on the back…
ATTENTION!
Do not
leave icemaker
unattended when panels are off
Tech Support: 1.800.233.1940
1
M
&
2
M
c
3
U
A
4
15
16
n
17
,
18
19
In
5
20
#51050 | 10.06.2016
Page 1
Top
Right Side
Front of
icemaker
(-OS) models
If switch is left on DRAIN for more than 10 min., a 2-beep alarm will sound every 5 seconds.
w
n
Wait
1 min.
Unplug
To Icemaker
Or Water Filter
SHUT OFF
REMOVE ICE
CLEAN
Storage
Bin
Page 22
