Honda Activa SCV110, Справочник по обслуживанию

Страница: 174 / 230

14-1
14. REAR WHEEL/BRAKE/SUSPENSION
SERVICE INFORMATION 14-1
TROUBLESHOOTING 14-2
REAR WHEEL 14-3
REAR BRAKE 14-4
SHOCK ABSORBER 14-7
SERVICE INFORMATION
GENERAL
• Riding on damaged rims impairs safe operation of the scooter.
• When servicing the rear wheel and suspension, support the motorcycle using a center stand or hoist.
• A contaminated brake drum or shoe reduces stopping power. Discard contaminated shoes, and clean a con
taminated drum with a high quality brake degreasing agent.
• After the rear wheel installation, check the brake operation by applying the brake lever.
• Use genuine Honda replacement bolts and nuts for all suspension pivots and mounting points.
• Refer to the brake system information (page 14-3).
• This scooter is equipped with the TUFFUP tube (rear tyre only).
• The TUFFUP tube is able to repair same as a usual tube. Follow bellow caution:
–
Do not inflate a TUFFUP tube larger than the tire size as you do in a conventional tube, or air will flow into the
liquid room and lower its performance
– When finding a hole inflate a TUFFUP tube to the same size as the inside of the tire and look for a hole where
liquid leaks out
– When fixing the TUFFUP tube, hold the area where a patch is attached higher than other parts of the tube so
that the liquid does not flow over the area. Then wipe off the liquid thoroughly and attach a patch firmly or it may
cause air leak
• TUFFUP tube cannot always prevent tire puncture.
• Always use proper size TUFFUP tube for the tire.
• Because of its construction, foreign object(s) may be stuck into the tube even if the tire seems to be inflated to the
proper pressure. If any foreign objects are found during maintenance, remove them, and repair as soon as
possible.
• Sometimes air leak does not stop after a nail etc. is removed from the tire. In that case, tapping the tread of the
tire several times can stop the air leak. Even if the air leak stops after tapping, it may starts leaking again. Repair
it as soon as possible.
• When a tire rim is wet or a tire seems under-inflated, check for any abnormalities on the tire and repair if
necessary.
• When the liquid contacts with your skin or eye(s), rinse with plenty of water immediately.
• Like a conventional tube, damage over 3.0 mm (0.12 in) cannot be repaired. In that case the whole tube must be
replaced.
• Always use a new TUFFUP tube that is proper for tire size when replacing.
• Always inflate to the specified pressure.
REPAIR POINT
Frequent inhalation of brake shoe dust, regardless of material composition could be hazardous to your health.
• Avoid breathing dust particles.
• Never use an air hose or brush to clean brake assemblies. Use an OSHA-approved vacuum cleaner.
14