Guardian 004700-0, Инструкция по установке и эксплуатации

Страница: 8 / 52

6
Section 1 – General Information
Recreational Vehicle Generator

The manufacturer does not recommend using
any gasoline containing alcohol (such as “gaso-
hol”). If using any gasoline containing alcohol, it
must not contain more than 10 percent ethanol,
and it must be removed from the generator dur-
ing storage. Do NOT use any gasoline
containing methanol. If using gasoline with alco-
hol, inspect more frequently for fuel leaks and
other abnormalities.
1.5.2 FUEL CONSUMPTION
‹
Model No Load 1/2 Load Full Load
004700-0
004708-0 0.24 0.35 0.55
Fuel consumption is in gal/hr.
1.5.3 ENGINE OIL REQUIREMENTS
‹
Use only high quality detergent oil rated with American
Petroleum Institute (API) Service Classification SF,
SG or SH. The recommended oil weights include the
following:
During summer months: SAE 30. An acceptable •
substitute is SAE 10W-30.
During winter months: SAE 5W-30. DO NOT USE •
SAE 10-W40.
Crankcase and oil filter capacity is approximately
800 mL or .84 U.S. quarts. Do NOT use special addi-
tives. See sections "Checking the Engine Oil Level"
and "Changing the Engine Oil and/or Oil Filter" for oil
level check and fill procedures.
1.5.4 ENGINE
‹
Type of Engine ................................... GN-220, Single-cylinder
Cooling Method ........................................................Air-cooled
Rated Horsepower .......................................7.8 @ 4,200 rpm
Displacement .................................................................. 220cc
Cylinder Block .........................Aluminum w/Cast Iron Sleeve
Type of Governor .............................Mechanical, Fixed Speed
Air Cleaner ........................Paper Element w/Foam Precleaner
Starter ....................................................... 12-volt DC Electric
Ignition System ..................... Solid-state w/Flywheel Magneto
Recommended Spark Plug
Champion ................................................................ RC14YC
AC .................................................................................. R45S
Fram Autolite .....................................................................65
Spark Plug Gap ....................................... 0.030 inch (76 mm)
Recommended Minimum Battery .............. 400 Cold-cranking
Amperes
1.5.5 GENERATOR
‹
Rated Maximum Continuous
AC Output (Gasoline) ...........................3,600 Watts (3.6 kW)
Rated Voltage ....................................................... 120 Volts AC
Rated Maximum Continuous
AC Current (Gasoline) ....................................... 30 Amperes
Phase .............................................................................. Single
Rotor RPM .......................................................................3,600
Number of Rotor Poles...........................................................2
Engine RPM .....................................................................3,600
Rated AC Frequency ....................................................... 60 Hz
Battery Charge Voltage ..........................................14 Volts DC
Battery Charge Current ................................ 2 Amperes (max)
Gasoline weight .....................................................170 Pounds
Length ....................................................749.8 mm (29.52 in.)
Width .....................................................483.1 mm (19.02 in.)
Height ....................................................342.2 mm (13.47 in.)
1.5.6 EMISSIONS COMPLIANCE PERIOD
‹
For non-handheld engines the Emissions Compliance
Period referred to on the Emissions Compliance
Label indicates the number of operating hours for
which the engine has been shown to meet Federal
emission requirements.
For engines less than 225 cc displacement, Category •
C=125 hours, B=250 hours, and A=500 hours.
For engines of 225 cc or more, Category C=250 •
hours, B=500 hours, and A=1000 hours.