Generac Power Systems MAGNUM MLT4060MVD, Руководство пользователя

Страница: 31 / 72

Operation
Owner’s Manual for MLT4060MVD Light Tower 27

Verify all winch cables are in good condition and
centered on each pulley. Do not use if cables are
kinked or beginning to unravel.

Check oil, coolant, and fuel levels. For more
information, refer to
General Maintenance .

Verify battery connections are secure.

Check the engine fan belt tension and condition.

Check the engine fan belt guard.

Check the engine exhaust system for loose or rusted
components.

Verify all covers are in place and secure.

Turn the battery disconnect switch ON (if equipped).
Raising Mast—Manual Winch
IMPORTANT NOTE: The mast is intended for use
ONLY to support the LED fixtures. Do not use the
mast as a hoist or for any other purpose.
1. Set up and level the unit. See Light Tower Setup .
2. See Figure 3-3 . Check the mast cables for
excessive wear or damage. Make sure the cables
are properly centered in each pulley (A). Check the
coiled electrical cord for damage.
3. Rotate the mast by loosening the mast rotation
knob (C) at the bottom of the mast. Turn the mast
until the lights face in the desired direction, and
then tighten the mast rotation knob to secure the
mast in position.
4. See Figure 3-3 . Use the winch (B) to slowly extend
the mast, making sure that the coiled electrical cord
is extending at the top sections of the mast. STOP
extending the mast when the colored mark on the
second mast section is visible as seen in Detail B.
IMPORTANT NOTE: Contact an ASD immediately if
the mast hangs up or the winch cable develops
slack
.
.
Figure 3-3. Winch and Pulley Locations—Manual
DANGER
Electrocution. DO NOT use the unit if
electrical cord is cut or worn through. Doing
so will result in death or serious injury.
(000263a)
WARNING
(000266)
Tipping hazard. Extend the outriggers and level the unit
before raising the mast. Keep the outriggers extended while
the mast is up. Failure to do so could cause the unit to tip
and fall and could result in death or serious injury.
WARNING
Tipping hazard. Do not extend the mast beyond the
colored mark on the second mast section. The unit
can become unstable and tip or fall, causing injury.
(000262)
WARNING
Personal Injury. Stop immediately if the mast hangs
up or the winch cable develops slack. Excess slack
could cause the mast to collapse, resulting in personal
injury or equipment damage.
(000265)
DETAIL B
STOP
A
B
C
008414