GENERAL INFORMATION & ROUTINE MAINTENANCE
Page A-5
Repair and Service Manual
Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notices, Cautions, Warnings and Dangers.
Removal of oil, tar, asphalt, shoe polish, etc. will require
the use of a commercially available vinyl/rubber cleaner.
The painted surfaces of the vehicle provide attractive
appearance and durable protection. Frequent washing
with lukewarm or cold water is the best method of pre-
serving the painted surfaces.
Do not use hot water, strong soap or harsh chemical
detergents.
Rubber parts should be cleaned with non-abrasive
household cleaner.
Occasional cleaning and waxing with non-abrasive prod-
ucts designed for ‘clear coat’ automotive finishes will
enhance the appearance and durability of the painted
surfaces.
Corrosive materials used as fertilizers or for dust control
can collect on the underbody of the vehicle. These mate-
rials could cause corrosion of underbody parts. It is rec-
ommended that the underbody be flushed occasionally
with plain water. Thoroughly clean any areas where mud
or other debris can collect. Sediment packed in closed
areas should be loosened to ease it’s removal, taking
care not to chip or otherwise damage paint.
If the engine does not start or runs improperly after washing,
remove the spark plug wire (by pulling the spark plug boots,
never the wires) and blow them dry. Reinstall the wires.
Remove moisture from coil by blowing across top.
VEHICLE CARE PRODUCTS
To help maintain the vehicle, the manufacturer has sev-
eral products, available through a local Distributor, an
authorized Branch, or the Service Parts Department,
among them are
• Touch-up paint specially formulated to match vehi-
cle colors for use on both metal and TPE (plastic)
bodies. (P/N 28432-G**)
• Multi-purpose Battery Protectant formulated to form
a long-term, flexible, non-tacky, dry coating that will
not crack, peel or flake over a wide temperature
range. (P/N 606312)
• Multi-purpose Hand Cleaner is an industrial
strength cleaner containing no harsh solvents, yet
gently lifts grease off hands. May be used with or
without water. (P/N 607636)
• Plexus plastic cleaner and polish removes minor
scratches from windshield. (P/N 606314)
HARDWARE
Periodically the vehicle should be inspected for loose
fasteners. Fasteners should be tightened in accordance
with the Torque Specifications table (Ref. Fig. 6). Use
care when tightening fasteners and refer to the sections
in this manual for specific torque values.
Generally, two grades of hardware are used in the vehi-
cle. Grade 5 hardware can be identified by the three
marks on the hexagonal head. Unmarked hardware is
Grade 2 (Ref. Fig. 6)
NOTICE
