CYBEX 600T, Руководство по обслуживанию

Страница: 17 / 55

Cybex 600T Treadmill service Manual
adjustment bolts 1/2 of a turn (clockwise). Adjust the belt until no further
slipping is felt.
Running
Belt
Maintenance
The running belt and deck should be checked periodically for any excessive
wear. The belt may need minor adjustments. Use the following section to help
keep your
BOOT
operating properly.
Checking the Belt and Deck Surfaces -In an effort to make sure that the
running belt operates properly, visually inspect the belt on a weekly basis to
make sure that there are no tears or fraying in the belt material.
To inspect the edges of the belt, it is necessary to remove the plastic side rails.
Follow these steps:
1. Turn the power off.
A. Turn the main power switch on the front panel to the off (0) position.
B. Unplug the treadmill from the power outlet.
!
WARNING: When removing or installing the side rails be sure to wear
work gloves to protect against any sharp edges.
2. Remove the plastic end caps and side rails.
A. Remove the Phillips head screws that fasten each of the plastic end
caps in place and set aside. See Figure 2.
B. Grab the side rail and firmly slide it out towards the back of the
treadmill.
F i gure 2
Table
of Contents
i
Read
All Instructions
&
Warn i ngs
ii
Important Safety Instructions
iv
About
This Manual
Important
Voltage iv
FCC Compliance .
iv
V Declaration of
Conformity
vii
Table
of Contents
1
Safety
Warning
DecaJs. . . . . . . . . .. 1 - 1
Caution DecaJs . . . . . . . . . .. 1 - 2
2
Technical
Specifications . . . . . . . . . . . . 2 - 1
3
Maintenance
3-1
Running
Belt ..
4
Troubleshooting
Test Mode . . . . . . . . . . . . . . 4 - 1
LED Functions . . . . . . . . . .. 4 - 1
Key
Functions 4 - 2
Codes . . . . . . . . . . . ..
4 - 2
Speed Sensor Adjustments. 4-3
5
RemovaJ &
Replacement
Running Deck . . . . . . . . . . . .
5-1
Runn i ng Belt . . . . . . . . . . . ..
5 - 5
Front
Roller . . . . . . . . . . . . . . 5-5
Drive Belt . . . . . . . . . . . . . . ..
5-5
Rear Roller. . . . . . . . . . . . . . .
5-6
Drive
Motor . . . . . . . . . . . . .. 5-7
Motor
. . . . . . . . . . . .
5- 1 0
Elevation
Motor 5-13
Lower Contro l Board
5 - 15
Power Cables
5-16
Une Filter 5 - 17
Power
Switch 5-17
Power
Cord
Inlet
5-18
Display Board 5-18
Heart Rate
Board 5 - 20
Lower
Display Board 5-21
Polar Board 5-21
Upper
Display
Cable 5-22
Lower Display
Cable 5-24
Display
5-25
6
Diagrams
Parts Ust . . . . . . . . . . . . . ..
6 - 1
Exploded
.•. . • . • . •..
6 - 3
SOOT
Schematic
6-4
7
Customer
Contacting
. . . . . . . .
7 - 1
SeriaJ Number & Voltage . . . .
7 - 1
Return Material Authorization
(RMA) 7 - 1
Damaged Parts. . . . . . . . . ..
7-2
8
Index 8 - 1
Page 3-3