TELL-ONE
CRAMARO TS S.r.l. – 37044 COLOGNA V.TA (VR), ITALY - VIA QUARI DESTRA, 71/G TEL. +39 0442/411688 / FAX + 39 0442/411690
E-MAIL [email protected] WEB : http://www.cramaro.com - Manual no. MTO001-EN-ED 02 – date 26/07/13
Page 19
INSTRUCTION!
During rolling up, should the tarpaulin jam on the material in the container, try to lift it to
remove or overcome the obstacle with a rod WITHOUT LETTING THE TARPAULIN ROLL
UP BY ITSELF.
-
Application of a prohibition sign on the machine.
TROUBLESHOOTING
If the tarpaulin does not fully roll up around the housing, FIRST try and unroll a few metres of it again
and roll it up again.
If after this step it does not roll up, check whether:
I. The side FLAPS are properly STRETCHED on the upper tarpaulin and are not TANGLED or
STUCK on some protruding part of the container.
II. The REAR TUBE used to tension the tarpaulin is STUCK on some protruding part of the
container.
III. Any SIDE ROPES are not HOOKED somewhere.
IV. The tarpaulin is DIRTY and if the dirt caused the tarpaulin to STICK to the sides of the
container or on itself, thereby preventing it from being rolled up correctly.
V. The rolling up SPRING has lost its retraction force or is broken.
ROUTINE MAINTENANCE
ROUTINE MAINTENANCE MUST BE CARRIED OUT BY THE OWNER
INSTRUCTION!
USE ORIGINAL CRAMARO TS SPARE PARTS.
Visual checks
EXECUTION TIMETABLE
Before use
Check the state of the side anchor ropes of the tarpaulin, they must NOT be frayed or torn.
If the rope is torn replace it with one of the same type (in POLYESTER Ø 5 mm,
sliding).
Verify the side anchor hooks of the ropes to the container are intact.
Make sure the rear hooks holding the tarpaulin TENSIONING ROD are intact.
Make sure the metalwork (housing) is intact.
Make sure the tarpaulin is intact.
Verify all rivets are present on the "cobra" hooks.
