C25000 O&S Manual
46
C25000-OM-EN-05
5.7: Fuel Filter Element
Engines are equipped with a primary fuel filter and a final fuel filter. Both
filters are replaced at the same 500hour interval. Please refer to engine
manual for full instructions on how to correctly replace fuel filter elements.
5.8: Air Filter Elements
The air filter unit is located in the engine compartment on the right hand side of
the truck. The air filter primary element must be cleaned after every 100 hours
of use and replaced at intervals of 500 hours of use (or 8 months depending
on which occurs first). The safety filter only needs to be cleaned if the primary
filter has been damaged.
In order to clean/replace the air filter elements take the following steps:
1. Shut off the engine. Open the bonnet on the
right hand side of the machine and locate the
air filter unit to the right of the engine.
2. Unlatch and remove the housing service cover.
3. Remove the primary filter. Push down on the
filter using the handle - this will tilt the filter to
approximately 5° - to loosen the filter gasket
seal. Use the handle to pull the filter out of the
housing.
4. Remove the safety filter.
Note:
The safety filter
only needs to be replaced at every third primary
filter change. Using the plastic handle on the
face of the safety filter, pull the filter toward the
centre of the housing and remove.
5. Inspect the new filter before installing. Visually
check for cuts, tears, or indentations on the
sealing surfaces before installation. If any
damage is visible do not install.
6. If replacing the safety filter slide the filter into
the housing outlet side at an angle and insert
the safety filter tab into the positioning slot.
Push the filter into place until it seats firmly and
evenly within the housing.
