POWERDRIVE 3 – MODEL 26560
Troubleshooting
Page 6-14
2008-2011 Domestic Battery Charger Maintenance and Service Manual
6
Charger output is low
Failed rectifier
Test Procedure 4 – Rectifier on page 6-20
Transformer coil short-circuit failure
Test Procedure 6 – Transformer on
page 6-22
Onboard computer malfunction
Test Procedure 2 – Onboard Computer on
page 6-19
Charger turns off too soon
AC power supply was shut off
Test Procedure 3 – AC Power and
Continuity Test of AC Circuit on page 6-19
Onboard computer malfunction
Test Procedure 2 – Onboard Computer on
page 6-19
Batteries may be fully charged
Test Procedure 7 – Battery State of
Charge Test on page 6-23
Charger goes to 16 hour time out
Onboard computer malfunction
Test Procedure 2 – Onboard Computer on
page 6-19
Extremely discharged batteries or cold
temperature
Recharge batteries
Failed or weak battery
See Batteries section in the appropriate
maintenance and service manual
AC line fuse blows or AC circuit
breaker trips
AC cord is shorted
Test Procedure 8 – Continuity on
page 6-23
Failed transformer
Test Procedure 6 – Transformer on
page 6-22
Incorrect charger wiring
Check battery charger wiring
Battery warning light illuminates for
ten seconds at four second intervals
(with DC charger cord plugged in) (25
seconds, at 10 second intervals for
Precedent vehicles)
AC power interrupted
Test Procedure 3 – AC Power and
Continuity Test of AC Circuit on page 6-19
Onboard computer malfunction
Test Procedure 2 – Onboard Computer on
page 6-19
Charger failure
See Testing Charger Operation on
page 6-11
16 hour time out
See Battery Warning Light on page 6-2
Battery or batteries need to be replaced
See Batteries section in the appropriate
maintenance and service manual
Battery warning light illuminates for
ten seconds at four second intervals
(with DC charger cord unplugged) (25
seconds, at 10 second intervals for
Precedent vehicles)
Batteries are getting close to full
discharge capacity
Recharge batteries (golf round may be
completed first)
Onboard computer malfunction
Test Procedure 2 – Onboard Computer on
page 6-19
Battery or batteries need to be replaced
See Batteries section in the appropriate
maintenance and service manual
POWERDRIVE 3 BATTERY CHARGER TROUBLESHOOTING GUIDE
SYMPTOM
POSSIBLE CAUSES
CORRECTIVE ACTION
Содержание 2008-2011
