3
SAFETY AND OPERATION PRECAUTIONS
___________________________________________________________________________________
Because an air compressor is a piece of machinery with moving and rotating parts, the same precautions
should be observed as with any piece of machinery of this type where carelessness in operation or
maintenance is hazardous to personnel. In addition to the many obvious safety rules that should be
followed with this type of machinery, the additional safety precautions as listed below must be observed:
1.
Read all instructions completely before operating air compressor or unit.
2.
For installation, follow all local safety codes, as well as the Occupational Safety and Health Act
(OSHA).
3.
Do not attempt to remove any compressor parts without first relieving the entire system of pressure.
4.
Do not attempt to service any part while machine is in an operational mode.
5.
Do not operate the compressor at pressures in excess of its rating.
6.
Do not operate compressor at speeds in excess of its rating.
7.
Periodically check all safety devices for proper operation. Do not change pressure setting or restrict
operation in any way.
8.
Be sure no tools, or rags or loose parts are left on the compressor or drive parts.
9.
Do not use flammable solvents for cleaning the air inlet filter or element and other parts.
10.
Exercise cleanliness during maintenance and when making repairs. Keep dirt away from parts by
covering parts and exposed openings with clean cloth or Kraft paper.
11.
Do not operate the compressor without guards, shields and screens in place.
12.
Do not install a shut-off valve in the discharge line, unless a pressure relief valve, of proper design
and size, is installed in the line between the compressor unit and shut-off valve.
13.
Do not operate compressor in areas where there is a possibility of ingesting flammable or toxic
fumes.
14.
Be careful when touching the exterior of a recently run engine - it may be hot enough to be painful
or cause injury.
15.
Inspect unit daily to observe and correct any unsafe operating conditions found.
16.
Do not "play around" with compressed air or direct air stream at body, because this can cause
injuries.
17.
Compressed air from this machine absolutely must not be used for food processing or breathing air
without adequate downstream filters, purifiers and controls.
18.
Always use an air pressure regulating device at the point of use, and do not use air pressure greater
than marked maximum pressure of attachment.
19.
Check hoses for weak or worn condition before each use and make certain that all connections are
secure.
20.
Always wear safety glasses when using a compressed air blow gun.
The user of any air compressor package manufactured by Champion is hereby warned that failure to
follow the preceding Safety and Operation Precautions can result in injuries or equipment damage.
However, Champion does not state as fact or does not mean to imply that the preceding list of Safety and
Operating Precautions is all inclusive, and further that the observance of this list will prevent all injuries or
equipment damage.
Содержание BDR5K
Страница 2: ......
Страница 32: ...30 UNIT HAZARD DECALS ...