100794 - 9,000 LB. (4082 KG) WINCH
ASSEMBLY
10
OPERATION
General Tips for Safe Operation
Your winch is rated at a 9000 lb. (4082 kg) capacity in
first layer (max) when spooling the first rope layer on the
drum. Overloads can damage the winch, motor and/or
wire rope. For loads over 50% we recommend the use
of the pulley block/snatch block (included) to double the
wire rope line. This will aid in two ways:
–
reduce the number or rope layers on the drum,
as well as,
–
reduce the load on the wire rope by as much as
50%.
When doubling the line back to the vehicle, attach to the
tow hook, frame or other load bearing part. The vehicle
engine should be kept running during operation of the
winch to minimize battery drain and maximize power
and speed of the winch. If the winch is used for a
considerable time with the engine off the battery may be
drained and too weak to restart the engine.
Get to know your winch before you actually need to use
it. We recommend that you set up a few test runs to
familiarize yourself with rigging techniques, the sounds
your winch makes under various loads, the way the cable
spools on the drum, etc.
Inspect the wire rope and equipment before each use.
A frayed or damaged rope shall be replaced immediately.
Use only manufacturer’s identical replacement rope with
the exact specifications.
Inspect the winch installation and bolts to ensure that all
bolts are tight before each operation. Store the remote
control inside your vehicle in a place that it will not be
damaged.
Any winch that appears to be damaged in any way,
is found to be worn, or operates abnormally MUST
BE REMOVED FROM SERVICE UNTIL REPAIRED. It is
recommended that the necessary repairs be made by
a manufacturer’s authorized repair facility.
Pull only on areas of the vehicle as specified by the
vehicle manufacturer. Only attachments and/or adapters
supplied by the manufacturer are to be used.
Self Recovery
Locate a suitable anchor such as a strong tree trunk or
boulder. Always use a sling (not included) as an anchor
point.
A roller fairlead (included) will help guide the wire rope
and to reduce binding on short side pulls. Do not winch
from an acute angle as the wire rope will pile up on one
side of the drum causing damage to wire rope and the
winch.
Correct
Incorrect
