Campbell Hausfeld PW2575, Инструкция по эксплуатации и каталог запасных частей

Страница: 15 / 68

Maintenance
MAINTENANCE SCHEDULE
Maintenance Schedule Action needed
Daily • Check water inlet screen and
filter.
• Check engine oil levels. Fill as
necessary.
• Check gasoline level. Fill as
necessary.
After first 5 hours of
operation • Change engine break-in oil. Use
10W-30 automotive detergent
oil. See your Honda Owner’s
manual for specific information.
Every 25 hours of
operation • Change oil if operating under
heavy load or high ambient
temperature.
• Clean or replace paper air
cleaner cartridge. Tap gently to
remove dirt.
Every 50 hours of
operation • Change oil.
• Replace spark plug.
Each 100 hours of
operation or every 3
months • Replace paper air cleaner
cartridge.
• Change engine oil.
15
Model PW2575
www.chpower.com
Observe regular maintenance intervals to ensure maximum
performance and life from the pressure washer. Refer to the
schedule for recommended maintenance. If you operate the
pressure washer in dusty conditions, perform maintenance
checks more often.
ENGINE OIL CHANGING INSTRUCTIONS
Drain the engine oil when the engine is warm. Warm oil drains
quickly and completely.
1. Turn the fuel valve to the OFF position to reduce the
possibility of fuel leakage.
2. Place a suitable container next to the engine to catch the
used oil.
3. Remove the oil filler cap/dipstick and drain the oil into the
container by tipping the engine toward the oil filler neck.
Please dispose of used motor oil in a manner that is compatible
with the environment. We suggest you take used oil in a sealed
container to your local recycling center or service station for
reclamation. Do not throw into the trash, oust it on the ground,
or pour it down a drain.
4. With the engine in a level position, fill to the upper limit
mark on the dipstick with the recommended oil.
Running the engine with a low oil level can
cause engine damage.
5. Reinstall the oil filler cap/dipstick securely.
PUMP OIL CHANGING INSTRUCTIONS
Changing or refilling the oil in the pump requires removal of the
pump from the engine and should not be required unless oil
has leaked out due to worn or damaged oil seals in the pump. If
oil has leaked out of the pump, bring the pressure washer to a
certified Campbell Hausfeld service center for repair.
TECHNICAL AND CONSUMER INFORMATION
Horizontal Oriented Pressure Washers
Engine Oil Type SAE 10W-30
SAE 30W (Above 60° F)
Engine Oil Capacity
Honda Engines 18.5 fl. oz.
Engine Fuel Capacity
Honda Engines 0.29 gallons
Pump Oil Type
Wobble Pumps 80w90 gear oil
Pump Oil Capacity
Vertical Wobble Pumps 2.7 fl. oz.
Pump Detergent Suction
Water to detergent ratio 8 to 1 (12% detergent)
Water Supply Requirements
Minimum inlet pressure 20 psi
Maximum inlet pressure 100 psi
Maximum inlet temperature 100° F
Minimum inlet flow rate 5 gpm
Inlet garden hose size 5/8 inch I.D.
Maximum inlet garden hose
length 50 feet
Figure 21 - Oil drain and fill locations
Upper limit
Oil filler
cap/dipstick
Oil filler neck