70
Propulsion System
Lubricant in impeller shaft reservoir
should be drained and reservoir cleaned.
Refilled with BOMBARDIER synthetic
polyolester oil 75W90 GL5 type C gear
lube, as per following table. Refer to an
authorized dealer for this operation.
CAUTION:
Use only BOMBARDIER
jet pump oil or equivalent synthetic
gear oil, otherwise component ser-
vice life could be reduced. Do not
mix oil brands or types.
Lubricate PTO flywheel at grease fit-
ting with synthetic grease.
CAUTION:
Do not lubricate exces-
sively. Immediately stop when a
slight movement is noticed on rub-
ber boot. Never leave any clothing,
tool or other objects in the engine
compartment.
1. PTO flywheel
2. Grease fitting
3. Drive shaft boot
Boat Cleaning/Repair
Wash the body and the trailer with soap
and water solution (only use mild deter-
gent). Rinse thoroughly with fresh wa-
ter. Remove any marine organisms
from the hull.
CAUTION:
Never clean apparent fi-
berglass and plastic parts with
strong detergent, degreasing agent,
paint thinner, acetone, etc.
Stains may be removed from seats and
fiberglass with Knight’s Spray-Nine* from
Korkay System Ltd or the equivalent.
If repairs are needed to the body or to
the hull contact your dealer. For paint
touch up to mechanical parts use Bom-
bardier spray paint. For minor gelcoat
repairs, a Bombardier repair kit is avail-
able. Replace damaged labels/decals.
Clean the bilge with hot water and de-
tergent or with bilge cleaner. Rinse
thoroughly. Unscrew drain plug(s) and
lift front end of sport boat to complete-
ly drain bilge.
Antifreezing Protection
In cool regions where freezing point tem-
perature may be encountered, cooling
system must be filled with water and an-
tifreeze solution. (50% water, 50% anti-
freeze).
CAUTION:
Antifreeze mix must be
fed in cooling system. Otherwise wa-
ter will freeze in engine(s)/exhaust
system(s) causing severe damage.
NOTE:
When available, it is recom-
mended to use biodegradable anti-
freeze compatible with internal com-
bustion aluminum engines.
CAUTION:
Always use ethylene gly-
col antifreeze containing corrosion
inhibitors specifically recommended
for aluminum engines.
NOTE:
The engine(s) will not have to
run during this operation but should
have been run before to exhaust wa-
ter from cooling system components.
IMPELLER SHAFT RESERVOIR
MODEL
CAPACITY (mL)
Sportster LE
115
Sportster LT
80
F01I0BZ
2
1
3
lmo2002_003a.book Page 70 Wednesday, November 14, 2001 2:39 PM
