−18−
5-9 Supply of fuel
Stay the machine on the level.
Fuel guage approaches E (Empty), supply
fuel (diesel) immediately.
Over-supply of the fuel is possible to cause
the overflow of fuel from the fuel cap, when
operating the machine on the slope.
* Use the low sulfur or ultra low sulfur
diesel fuel
*
Capacity of Fuel tank is about 47ℓ.
E
F
14
F U E L
1 2
34
Danger
●
Be sure to keep the following precaution, because the fuel is
highly flammable.
(Put any naked flame and cigarette off.) Keep fire away when
suppling the fuel.
●
Before suppling the fuel, stop the engine and cool it down
enough.
●
To prevent a fire, keep the machine clean and free of dust,
grease and oil.
●
Clean up any spilled fuel.
●
Don't oversupply the fuel. It may cause the fire, if the fuel
overflow from the fuel tank. Use diesel fuel only. Be sure not to
use gasoline.
●
Don't supply gasoline.
5-10 Inspection of battery
Refer to the Battery's instruction manual.
The machine exported from Japan mounts
the battery of refillable type. (FX105D31R)
Inspect and maintenance the battery
periodically.
Check the electrolyte level between
"UPPER LEVEL" (maximum level line) and
"LOWER LEVEL" (minimum level line).
When the electrolyte level is falling below to
half between "UPPER LEVEL " and
"LOWER LEVEL", add the refining water to
"UPPER LEVEL" immediately.
The replacement battery (EXIDE 27-60),
B a r o n e s s r e c o m m e n d s t o u s e , i s
maintenance-free. It may cause injury and
accident to refill water in force. Be sure not
to maintenance it.
UPPER LEVEL
LOWER LEVEL
Danger
●
Do not drink electrolyte and avoid contact with skin, eyes or
clothing. Wear protective glasses and protective clothes.
●
Charging battery, battery generate explosive hydrogen gas as
battery electrolyte contains sulfuric acid which is deadly poison
and causes severe burns.
●
Never smoke near the battery and keep sparks and flames away
from it.
●
When removing the battery, remove the negative (-) cable first,
and positive (+) cable last. Install the battery, assemble the
positive (+) cable first and negative (-) cable last.
●
When you connect the battery cables, connect the positive and
negative side correctly. When you mistake, the battery and the
electrical equipment may be damaged. (The red-color cable is
the positive side.)
●
If a dry cloth is used to clean the battery, the static electricity
may occur and there is danger of fire or explosion.
