-
2
-
n
WARNING
:
All barbecues and carts are designed for outdoor use only and
cannot be installed in or on boats.
This barbecue is not intended to be installed in or on recreational
vehicles.
All barbecues are not intended for commercial use.
n
WARNING
Fuels used in gas or oil-fired appliances and the products of
combustion of such fuels, contain chemicals known to the
State of California to cause cancer, birth defects and/ or
other reproductive harm.
This warning is issued pursuant to California Health &
Safety Code Sec. 25249.6.
n
WARNING
Failure to comply with these instructions could result in
a fire or explosion that could cause serious bodily
injury, death, or property damage.
n
WARNING
Your grill will get very hot.
Never lean over the cooking
area while using your grill. Do not touch cooking surfaces,
grill housing, grill lid or any other grill parts while the grill is in
operation, or until the grill has cooled down after use.
Failure to comply with these instructions may result in
serious bodily injury.
You have bought a quality gas product from Barbeques
Galore. All gas products require careful installation and or assem-
bly and pre-operational testing. We recommend that our trained
staff assemble, test and if necessary install your new purchase for
you.
Barbeques Galore cannot be held responsible for any
damages to persons or property resulting from improper assembly
or installation.
If you chose to assemble, test and install your own unit, please
follow the manufacturer’s instructions explicitly.
FOR OUTDOOR USE ONLY
This outdoor cooking gas appliance shall be used only outdoors
and shall not be used in a building, garage or any other enclosed
area.
This Outdoor Cooking Gas Appliance is not intended to
be installed in or on recreational vehicles and/or boats.
GAS PRESSURE
The
Natural Gas
Grill is designed to operate on Natural
Gas at a gas pressure regulated at 4" water column (W.C.)
when equipped with the correct Natural Gas Orifice on the
valves and a
Natural Gas Regulator
on the supply line.
The
Propane Gas
Grill is designed to operate on propane at a
gas pressure regulated at 11" water column (W.C.) when equipped
with the correct Propane Orifices on the valves and a
Propane
Regulator
on the supply line.
GENERAL INFORMATION
This installation must conform with local codes or, in the absence
of local codes, with either the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA
B149.1, or Propane Storage and Handling Code, B149.2
CAUTION: LEAK CHECKING
Check all gas connections with a soap solution to be sure they
are tight and leakproof. To make soap solution, mix one part water
with one part liquid detergent. With heat control knobs at "OFF
position, turn gas supply on. Apply the mixture to all gas pipe con-
nections. Soap bubbles will appear if connections are not properly
sealed; repair as necessary. Never test for gas leaks with a lighted
match or open flame.
PROPANE MODELS:
Correct LP Gas Tank Use
LP gas side burner models are designed for use with a stan-
dard
20 lb.
Liquid Propane Gas (LP gas) tank, not included with
barbecue box.
Never
connect your side burner to an LP gas tank
that exceeds this capacity. A tank of approximately 12 inches in
diameter by 18-1/2 inches high is the maximum size LP gas tank to
use. A Propane tank with an OPD (Overfill Prevention Device) must
be used. This safety feature prevents the tank from being over-
filled which can cause malfunction of the LP gas tank, regulator
and/or side burner.
The LP gas tank must be constructed and marked in accor-
dance with the Specifications for LP-Gas Cylinders of the U.S.
Department of Transportation (D.O.T.) or the National Standard of
Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for
Transportation of Dangerous Goods; and Commission, as applica-
ble. The LP gas tank must have a listed overfilling prevention
device and a cylinder connection device compatible with the con-
nection for outdoor cooking appliances.
Also, be sure to read and follow all LP instructions on the fol-
lowing page.
NOTE:
If the outdoor cooking gas appliance is not in use, the gas
must be turned off at the supply cylinder.
(a) Do not store a spare LP-gas cylinder under or near this
appliance;
(b) Never fill the cylinder beyond 80 percent full; and
(c) If the information in (a) and (b) is not followed exactly, a
fire causing death or serious injury may occur.
1.
The LP gas tank has a shutoff valve, terminating in an LP gas
supply tank valve outlet, that is compatible with a Type 1 tank
connection device. The LP gas tank must also have a safety
relief device that has a direct communication with the vapor
space of the tank.
2.
The tank supply system must be arranged for vapor withdraw-
al.
3.
The LP gas tank used must have a collar to protect the tank
valve.
!
Never
connect an unregulated LP gas tank to your gas grill.
The gas regulator assembly supplied with your gas grill is
adjusted to have an outlet pressure of 11" water column (W.C.)
for connection to an LP gas tank.
!
Only use the regulator and hose assembly supplied with your
gas grill. Replacement regulators and hose assemblies must be
those specified by manufacture.
!
Have your LP gas tank filled by a reputable propane gas dealer
and visually inspected and re-qualified at each filling.
!
Never fill the gas tank beyond 80% full. Have your propane gas
Safety Information
Содержание Turbo CG3TCBN
Страница 2: ......
