ABS (ANTI-LOCK BRAKE SYSTEM)
4-83
NOTICE
ECA13540
Brake fluid may damage painted surfaces
and plastic parts. Therefore, always clean up
any spilt brake fluid immediately.
14.Bleed:
• Brake system
Refer to “BLEEDING THE HYDRAULIC
BRAKE SYSTEM (ABS)” on page 3-14.
15.Check the operation of the hydraulic unit ac-
cording to the brake lever and the brake ped-
al response. (Refer to “HYDRAULIC UNIT
OPERATION TESTS” on page 4-83.)
NOTICE
ECA14770
Always check the operation of the hydraulic
unit according to the brake lever and the
brake pedal response.
16.Delete the fault codes. (Refer to “[C-1] DE-
LETING THE FAULT CODES” on page
8-218.)
17.Perform a trial run. (Refer to “CHECKING
THE ABS WARNING LIGHT” on page 4-86.)
EAS30201
HYDRAULIC UNIT OPERATION TESTS
The reaction-force pulsating action generated in
the brake lever and brake pedal when the ABS
is activated can be tested when the vehicle is
stopped.
The hydraulic unit operation can be tested using
the following two methods.
• Hydraulic unit operation test 1: this test checks
the function of the ABS after the system was
disassembled, adjusted, or serviced.
• Hydraulic unit operation test 2: this test gener-
ates the same reaction-force pulsating action
that is generated in the brake lever and brake
pedal when the ABS is activated.
Hydraulic unit operation test 1
WARNING
EWA13120
Securely support the vehicle so that there is
no danger of it falling over.
TIP
Two people are necessary to perform hydraulic
unit operation test 1.
1. Place the vehicle on the centerstand.
2. Turn the main switch to “OFF”.
3. Remove:
• Upper inner panel (right)
Refer to “GENERAL CHASSIS (2)” on page
4-5.
4. Check:
• Battery voltage
Lower than 12.8 V
→
Charge or replace the
battery.
TIP
• If the battery voltage is lower than 12.8 V,
charge the battery, and then perform hydraulic
unit operation test 1.
• If the battery voltage is lower than 10 V, the
ABS warning light comes on and the ABS does
not operate.
5. Connect the test coupler adapter “1” to the
ABS test coupler “2”.
Battery voltage
Higher than 12.8 V
Test coupler adapter
90890-03149
1
2
Summary of Contents for FJR13AG
