GB
04
ASSEMBLY
Read these instructions and this manual in its
entirety before you attempt to assemble or ope-
rate your new lawn mower.
IMPORTANT:
THIS LAWN MOWER IS SHIPPED
WITHOUT OIL OR GASOLINE IN THE ENGINE.
Your new lawn mower has been assembled at the
factory with the exception of those parts left unass-
embled for shipping purposes. All parts such as nuts,
washers, bolts, etc., necessary to complete the ass-
embly have been placed in the parts bag. To ensure
safe and proper operation of your lawn mower, All
parts and hardware you assemble must be tightened
securely. Use the correct tools as necessary to en-
sure proper tightness.
I.TO REMOVE LAWN MOWER FROM
CARTON
l
Remove loose parts included with mower.
l
Cut down two end corners of carton and lay end
panel down flat.
l
Remove all packing materials except padding
between upper and lower handle and padding holding
operator presence control bar to upper handle.
l
Roll lawn mower out of carton and check carton
thoroughly for additional loose parts.
II. HOW TO SET UP YOUR LAWN MOWER
IMPORTANT:
UNFOLD HANDLE CAREFULLY
SO AS NOT TO PINCH OR DAMAGE CONTROL
CABLES.
l
Your handles may be adjusted for your mowing
comfort. Refer to Service and Adjustments section
of this manual.(
except 2in1 mower)
CAUTION: Wear protective gloves during
operation of setting up your mower.
III.TO ASSEMBLE GRASS CATCHER
l
Put grass catcher frame into grass bag with rigid
part of bag on the bottom. Make sure the frame han
dle is outside of the bag top.
l
Slip vinyl bindings over frame.
NOTE:
If vinyl bindings are too stiff, hold them in
warm water for a few minutes. If bag gets wet, let
it dry before using.
IV. ASSEMBLE ENGINE STARTER KNOB
l
Press down engine brake handle by left hand, and
meanwhile pull the knob of starter rope back to the
hook ring on upper handle, assemble. The rope into
the hook r ing through the opening of hook ring.
l
Always keep starter rope in hook ring during all
WARNING:
The safety position of start-
ing engine is at the back of upper handle.
Users must keep the rope always in the
middle of the hook ring during starting engine
and mowing work. It is danger to starting engine
away from the safety position, which will lead to
the risk of feet hurting.
mowing work.
Fig.3
Fig.4
Hook ring
Starter rope
Upper handle
Locking lever
Lift and turn to desired position
Locking lever
Push to lock it
Fig.2
Fig.1
CAUTION
: Unfold the handle carefully to avoid pinching
and damaging the control cables.
Remove any packing material from around control bar.
Lift and unfold upper handle to desired height
handle. Refer to Service and Adjustments section.
and pull two levers on both sides to lock upper
SERIAL NUMBER
THE MODEL AND SERIAL NUMBERS WILL BE FOUND
ON A DECAL ATTACHED TO THE REAR OF THE
LAWNMOWER HOUSING.
YOU SHOULD RECORD BOTH SERIAL NUMBER AND
DATE OF PURCHASE AND KEEP IN A SAFE PLACE FOR
FUTURE REFERENCE.
DATE OF PURCHASE
We recommend that you write down the serial number
and purchase date in your user manual, so that you will
always have it at hand.
Note
The lawnmowers' net weight is depending on the different model of engine.
CUSTOMER RESPOSIBILITIES
l
Read and observe the safety regulations contained
in this manual.
l
Follow a regular schedule for maintaining, caring for
and using your lawnmower.
l
Follow the instructions in the "Customer responsi-
bilities" and "Storage" sections of this owner's manual.
l
Remember that the operator is responsible for
accidents with other persons or their property.
CONGRATULATIONS
on your purchase of a new
lawnmower. It has been designed, engineered and
manufactured to give you the best possible depen-
dability and performance.
Should you experience any problem you cannot
easily remedy, please contact the nearest authorized
service center/department. We have competent,
well-trained technicians and the proper tools to ser-
vice or repair this lawnmower.
Please read and retain this manual. The instructions
will enable you to assemble and maintain your lawn
mower properly. Always observe the
SAFETY
REGULATIONS
PRODUCT SPECIFICATIONS
GB
The gasoline lawn mower is for private use in the
home and garden suitable hobby. The mower may
only be used for the maintenance of grass or lawns
in the home and garden hobby can be used. Any
application that is not listed in this guide is prohibited.
T h e a b o v e u s e a n d s a f e t y i n s t r u c t i o n s m u s t b e
strictly adhered to. The manufacturer assumes no
l i a b i l i t y f o r a n y d a m a g e c a u s e d b y i m p r o p e r
operation, improper use, misuse, unauthorized rep
airs or alterations performed.
PROPER USE
These specifications are provided as a reference, these
are familiarized with the mower. We reserve the right to
make technical changes and other without advance
notification. It is possible that some details in this manual
does not coincide completely with your machine.
03
Residual risks
Even when the power tool is used as prescribed
it is not possible to eliminate all residual risk factors.
The following hazards may arise in connection with
the power tool's construction and design:
1.Damage to lungs if an effective dust mask is not worn.
2.Damage to hearing if effective hearing protection
is not worn.
3.Damages to health resulting from vibration emission
if the power tool is being used over longer period of
time or not adequately managed and properly
maintained.
Moving type
l
l
l
l
l
l
l
l
5 3 0
25-70
60
65
7 0
4 8 0
20- 75
7
8
Blade speed Max.
2800/min
2800/min
2800/min
Grass bag capacity (L)
Cutting height adjustment
Cutting Height (mm)
Cutting Width (mm)
MODEL
Motor
WB537SCV AL
WB487SCV AL
WB507SCV
492
25-76
7
Self-propelled
Self-propelled
Self-propelled
Net Weight
49kg
46kg
47kg
Drive speed
gears
3
gears
3
gears
3
20-85
70
8
2800/min
WB537SCV
5 3 0
Self-propelled
48kg
gears
3
25-70
60
8
2800/min
WB507SCV-3IN1
492
Self-propelled
46kg
gears
3
20-85
70
8
2800/min
WB537SCV-3IN1
5 3 0
Self-propelled
48kg
gears
3
WEIBANG 196cc WEIBANG 196cc WEIBANG 196cc WEIBANG 196cc WEIBANG 196cc WEIBANG 196cc
Close the side discharge door. The grass will be
c u t m u l t i p l e t i m e s u n d e r t h e c u t t i n g d e c k u n t i l
small enough to be left on the lawn. The mulched
grass will soon decay, becoming fertilizer for the
promotion of better grass growth.
MODEL 3in1 MOWER
Blade type
5020405010
4820403010
5310403010
5310403010
5020405040
5310403010
Sound power level(L
WA
)
Sound pressure level (L
PA
)
Vibration
K=1.5m/s
2
K=2.5dB(A)
K=2.5dB(A)
6.70m/s
7.73m/s
4.13m/s
4.16m/s
6.87m/s
7.81m/s
2
2
2
2
2
2
93.9dB(A)
95.1dB(A)
96.0dB(A)
94.0dB(A)
94.5dB(A)
82.7dB(A)
83.8dB(A)
84.6dB(A)
81.5dB(A)
82.0dB(A)
83.8dB(A)
95.1dB(A)
GM53J000000020
GM53J000000020
GM53J000000020
GM48G000000020
52.6kg
50.6kg
52.6kg
52.6kg
WB537SCV AL (BBC)
WB487SCV AL (BBC)
WB537SCV (BBC)
WB537SCV-3IN1 (BBC)
