83
Steering
The Volvo Penta sterndrive may feature a power assisted steering system. This consists of an engine mounted
pump, hoses, and steering cylinder. These work in conjunction with the helm and steering cable to move the tiller
arm, thus moving the drive unit.
The steering system for your Volvo Penta sterndrive is operated by a steering cable connected to the helm. Res-
tricting movement of the steering cable will limit or stop the steering system’s hydraulic assist.
NOTE!
Do not interfere with or restrict steering cable movement through the last 90° of bend at the engine. Do not
use cable retainers, clamps or tie straps. Using one or all of these could restrict the cable movement near the
engine. Do not tie wiring harnesses or other control cables to the steering cable. Make sure deck combing and
bulkheads allow for steering cable movement.
If the power steering system becomes inoperative, an increase in steering effort will be felt. Should this condition
occur, inspect for possible cause and correct condition if possible. If the power steering system cannot be correc-
ted on board, proceed at a reduced speed. The boat will be steerable, but with increased effort. See your Volvo
Penta dealer as soon as possible to correct your power steering system.
At slow speeds (no wake), your boat may tend to wander. This is normal and may be overcome by anticipating
bow direction and correcting with steering wheel. A slightly higher throttle and trim setting may also lessen wander
tendency. Changing weight distribution, aft to forward, can also affect slow speed steering.
Twin unit steering
Twin engine boats may have only one engine with a
fully operational power steering system. That power
steering system is on the starboard engine; therefore,
when operating on a single engine use the starboard
engine.
NOTE!
Using the port engine that does not have the
functional power steering system will cause an in-
creased effort in steering control, due to absence of
power assist.
Some twin engine boats may have both engine power
steering systems coupled together with a priority
valve. This allows the use of either engine to provide
power assist steering.
Steering bearing lubrication
Lubricate the steering ram (
A
) with a grease gun. Use
water resistant grease.
Summary of Contents for D3-110i-A
Page 1: ...OPERATOR SMANUAL D3 130A A D3 160A A D3 110i A D3 130i A D3 160i A ...
Page 99: ......
Page 100: ...7744362 English 12 2004 ...
