![background image](http://html1.mh-extra.com/html/thermo-king/thermolite-401414/thermolite-401414_installation-instructions-manual_1104423003.webp)
TK 56579-11-IS-EN (Rev. A, 10/20)
©2020 Trane Technologies
3
SB Installations
IIm
mp
po
orrtta
an
ntt:: BEFORE beginning the installation, refer to
“Solar Panel Installation Best
N
No
otte
e:: SB Installations require Adapter Bracket 401271 (sold separately) to install.
1. Attach adapter bracket ((4
40
01
12
27
71
1)) to solar panel assembly using supplied hardware as shown.
2. Position solar panel on top of unit towards the curbside avoiding the muffler, condenser air
outlet, and center mounting hole.
3. Using the mounting bracket as a template, mark and drill three 1/4'' dia. holes in the top front
cap, and three 3/16'' dia. holes in the rear frame member.
N
No
otte
e:: The charge controller for the 30W panel is located under the panel. If your controller has
LEDs, verify solar panel operation before securing panel onto unit. If panel is installed,
follow test procedure for non-LED controllers. See
“Solar Panel Test Procedures,” p. 11
.
4. Install front tabs of solar panel under the top cap and secure panel with supplied hardware
(use bolts through top front cap, use rivets for the frame).
5. Route harness down the rear curbside frame member to the angled frame support and along
the frame front member to the starter.
IIm
mp
po
orrtta
an
ntt:: Do not attach wiring harnesses to the fuel lines.
6. Attach positive (white/red) wire to the positive terminal on the starter solenoid (terminal with
the battery cable attached).
7. Attach negative (black) wire to CH terminal on throttle solenoid.
8. Secure harness as required with band wraps and anchors.
N
No
otte
e:: Avoid drilling holes in plastic bulkhead.
9. Clean door surface and attach supplied nameplate as shown.
10.Reinstall battery harness fuse and reconnect all power to unit.
N
No
otte
e:: Remaining kit components are not used.
Figure 3. Adapter bracket shown installed.
401271 bracket shown attached to solar panel
RCS1565