Operation - 5 - 4
CD397-Oper
August 2018 (Rev B)
Mobile Belt Loader Model 660-28
Operation
Operation Manual
Section 5
5.3.1.2
Transmission
Refer to the manufacturer’s recommendation contained in the transmission service manual.
If the engine is without the transmission, then spray flywheel and ring gear with one part recommended
engine oil, and one part Stoddard Solvent, or equivalent.
5.3.1.3
Drive
Axle
1. Drain drive axle by removing drain plug located on the underside of the differential carrier housing.
2. Reinstall plug after draining.
3. Attach a tag on steering wheel stating:
5.3.1.4
Tires
1. Raise the vehicle and chock the axles to prevent tire contact with ground.
2. Reduce air pressure to 15 psi (1.0 bar).
3. Spray tires with a rubber preservative.
5.3.1.5
Lubrication
Ensure all points are lubricated with specified grease, oil, etc.
5.3.1.6
Fluid
Levels
All fluid levels should be serviced, as necessary.
5.3.1.7
Wheel
Bearings
1. Repack wheel bearings.
2. Drain crankcase completely and renew the oil filter.
3. Drain antifreeze from radiator and engine block.
5.3.1.8
Battery
1. Disconnect the battery cables.
2. Remove the battery and store separately.
3. Slow charge the battery every one to two months.
CAUTION: Prolonged storage may be detrimental to transmission seals.
CAUTION: Oil has been removed from the drive axle.
WARNING:
TO AVOID INJURY TO PERSONNEL OR DAMAGE TO EQUIPMENT, ALWAYS USE
LIFTING EQUIPMENT, SAFETY JACKS, AND CHAINS WITH A SAFE MINIMUM
CAPACITY OF ONE AND A HALF (1.5) TIMES THE WEIGHT OF THE VEHICLE BEING
LIFTED.
NOTE:
Store the battery in cool dry well ventilated area not exposed to direct sunlight. A recom-
mended storeroom temperature of 32°F (0° C) to 90° C (32°C) should be maintained. If
stored outside, cover the battery for protection against dirt and moisture.
WARNING
Property
of
American
Airlines
