T
EE
J
ET
5000
O
PERATORS MANUAL
F
ERTILISER DISTRIBUTOR
,
O
THER TYPE WITH REG
.
4.19
NOTE!
If after some time it is found that the total amount spread is not the same as the
computer has calculated, check the machine’s settings, that the calibration and
encodements are correct.
If all the encodements are correct the following can be done:
If the fertiliser being used has been stored for a long time, or is damper or drier
than normal then these conditions can vary from the time of calibration to the
present.
This can be changed by altering the encoded/calculated CAL. FIG. by the amount
in percent that the present application varies from the required application.
Lower CAL. FIG. = higher application
DISTRIBUTOR WIDTH
The working width for the spreader used. Each spreader section is encoded
individually in centimetres (section 1 is the left-hand side of the machine).
NOTE!
All unused sections must be encoded as 0.
The total working width can be seen at the bottom of the display whilst encoding.
STEP%
Encode the size of the steps for the “STEP%” function. This % value is the same
for both + and -. The maximum step size is 99%.
DRIVE FACTOR
The speed at which the regulating system adjusts to the correct position. Min. = 1
and Max. = 500. Normal = 100.
If the regulation system adjusts to the correct application rate too slowly, then the
drive factor should be increased. If the system is constantly searching up & down
for the correct application rate then reduce the drive factor.
UNIFORM PRESSURE
Only used if the spreader can be split into sections.
If regulation is required when one or more sections are closed then uniform
pressure should be set to
OFF
. If no regulation is required when one or more
sections are closed then set uniform pressure to
ON
.
PULS/REV.
Encode the number of pulses per revolution for the RPM 2 sensor (sow axle).
Summary of Contents for 5000
