60B
ENGINE COMPARTMENT
V E H I C L E M A I N T E N A N C E
ENGINE COMPARTMENT-BS III
1. Brake Fluid Reservoir
2. Clutch Fluid Reservoir
3. Dip
Stick
4. Battery
5. Fuse
Box
6. Windshield
Washer
7. Radiator
Cap
8. Engine Oil Filler Cap
9. Service
Indicator
10. Air Filter
11. Engine Coolant Reservoir
1
2
4
5
6
10
11
8
7
3
9
61
V E H I C L E M A I N T E N A N C E
Changing engine oil
Change engine oil in the crankcase at recommended interval.
Engine oil should be drained while it is hot. Unscrew engine sump
drain plug and allow oil to drain out fully.
Changing oil filter
Unscrew and remove engine oil filter with the help of special tool, if
necessary. Engine oil filter is a spin-on type and cannot be
re-used. Change engine oil filter with every oil change.
Always use genuine engine oil filter for replacement.
Destroy the oil filter to avoid resale of the same by unscrupulous
people. Fill the new oil filter with fresh engine oil. Smear a little
engine oil on rubber gasket of new engine oil filter. Hand tighten
the filter fully and tighten it a further half turn with a special tool.
Do not overtighten engine oil filter as this may damage oil filter
and oil may leak out.
Before filling in fresh oil in the engine, refill the sump drain plug
using a new sealing washer. Tighten drain plug to 4 mkg torque.
Fill in specified quantity of fresh engine oil in the engine crankcase.
Start engine and run for a few minutes. Stop the engine and re-
check oil level after approx. 20 minutes. Top up if oil level is less
than midway between upper and lower marks on the dipstick.
1. Engine Oil Drain Plug
2. Engine Oil Filter
1
2
1. Engine Oil Filler Cap
2. Dip Stick
1
2
CHANGING ENGINE OIL & OIL FILTER
Ofrecido por www.electromanuales.com
