Tar River BPD-680, Operator'S Manual

Page: 9 / 36

9
BPD - 680/750 Post Hole Driver
•
Children should not be allowed on the machine.
•
Clear the area of small children and bystanders before moving the machine.
•
If using a towing unit, securely attach feeder by using a hardened 3/4” pin, a metal retainer, and safety
chains if required. Shift towing unit to a lower gear before going down steep downgrades, thus using the
engine as a retarding force. Keep towing vehicle in gear at all times. Slow down for corners and rough
terrain.
•
Make sure you are in compliance with all local and state regulations regarding transporting equipment on
public roads and highways. Lights and slow moving signs must be clean and visible by overtaking or
oncoming traffic when machine is transported.
•
Beware of bystanders, particularly children! Always look around to make sure that it is safe to start the
engine of the towing vehicle or move the unit. This is particularly important with higher noise levels and
quiet cabs, as you may not hear people shouting.
•
NO PASSENGERS ALLOWED! Do not carry passengers anywhere on, or in, the tractor or equipment,
except as required for operation.
•
Keep hands and clothing clear of moving parts.
•
Do not clean, lubricate or adjust your equipment while it is moving.
•
When halting operation, even periodically, set the tractor or towing vehicle brakes, disengage the PTO,
shut off the engine and
remove the ignition key.
•
Be especially observant of the operating area and terrain. Watch for holes, rocks or hidden hazards. Always
inspect the area prior to operation.
•
DO NOT operate near the edge of drop - offs or banks.
•
DO NOT operate on steep slopes as overturns may result.
•
Operate up and down (not across) intermediate slopes. Avoid sudden starts and stops.
•
Never attempt to check a pressurized system for leaks with bare hands! Wear proper hand and eye
protection . Use wood or cardboard when checking for leaks. Oil under pressure, can penetrate skin and
cause a serious medical emergency. If hydraulic fluid penetrates the skin, seek medical treatment
immediately!
•
Relieve pressure from the hydraulic lines by cycling all hydraulic controls after shut down and before
disconnecting. Hydraulic systems are under pressure and can cause serious injury or death.
•
Before digging, check with local utilities for under ground gas lines, phone lines or electrical lines. Serious
injury or death can occur from contact with electrical lines or explosion from ruptured gas lines.
During Operation
Important Safety Information