Super Hot AAA-3000 series, Installation And Service Manual

Page: 4 / 36

AAA Series Gas Boiler – Installation and Service Manual
4
ABOUT OUR MANUALS
Your Super Hot boiler has been provided with the following manuals:
• User's Information Manual - This manual is intended for the owner or user of the boiler and provides
information on routine operation and maintenance, and emergency shutdown.
•
Installation and Service Manual - This manual must only be used by a qualified heating installer,
service technician or gas supplier . Installation or service by anyone unqualified to do so may result
in severe personal injury, death or substantial property damage.
•
BTC Series Controller Manual - This manual must only be used by a qualified heating installer or
service technician . BTC Series Controller Manual contains detailed information on controller
operation applicable to single stage and two stage AAA boilers.
All manuals should be kept in the envelope provided and affixed adjacent to the boiler so that they are
readily available for future reference.
Lighting Instructions Section 1
1.1 SAFETY INSTRUCTIONS
WARNING
If you do not follow these instructions exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
A. BEFORE LIGHTING smell all around the
boiler area for gas. Be sure to smell next to
the floor because some gas is heavier than
air and will settle on the floor.
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
•
Immediately call your gas supplier from a
neighbor's phone. Follow the gas
supplier's instructions.
•
If you cannot reach your gas supplier, call
the fire department.
B. Use only your hand to push in or turn the gas
control knob. Never use tools. If the knob will
not push in or turn by hand, don't try to repair
it, call a qualified service technician. Force or
attempted repair may result in a fire or
explosion.
C. Do not use this boiler if any part has been
under water. Immediately call a qualified
service technician to inspect the appliance and
to replace any part of the control system and
any gas control which has been under water.
1.2 LIGHTING INSTRUCTIONS
Your boiler is equipped with an intermittent electronic ignition system which will automatically light a pilot
burner. After the module senses the pilot flame, the main gas valve and redundant valve will open,
allowing the pilot burner to ignite the main burner. The following section provides instructions for lighting
the boiler.