83 |
P a g e
OWNER’S
MANUAL
|
STARTRAC 263 4WD
–
8G
–
STAGE
–
V
CHAPTER -
7 DO’ AND DON’TS
DO
’S
DON’TS
ENGINE
A.
General
A.
General
•
Do release the starter key once the engine
has started.
•
Do not race the engine in neutral condition
•
Do check the proper functioning of oil
pressure gauge and battery charging
indicator once the engine has started.
•
Do not keep on continuously cranking the
engine with starter key. It will shorten the life
of battery.
•
Do get the tightness of cylinder head and
manifold nuts checked regularly
•
Do not do unnecessary idling
•
Do switch off the engine when tractor is
not in operation
B.
Air Inlet System
B.
Air Inlet System
•
Do inspect the element pre-cleaner. Clean
if necessary
•
Do not run the tractor if the air cleaner
assembly is defective as this will lead to
impure air being taken in and consequently
excessive wear of liners and piston rings.
C.
Fuel System
C.
Fuel System
•
Do drain sediments from the fuel tank
periodically.
•
Do not keep the fuel tank without a proper
sealing cap.
•
Do clean fuel tank thoroughly once in 500
hrs
•
Do not use contaminated fuel as it may affect
the operation of fuel injection pump and the
injectors.
•
Do
changes
filter
regularly
as
recommended in service schedule.
•
Do allow leakage through fuel pipe joints.
•
Do fill diesel in the tank at the end of the
day’s work to avoid condensation.
•
Do not spill fuel or oil while filling or topping
up. Use a funnel.
D.
Water Cooling System
D.
Water Cooling System
•
Do ensure that radiator is always filled
with clean (soft) water & radiator cap is
tight.
•
Do not run the tractor with the radiator cap
removed/non-acting radiator cap.
•
Do clean radiator front grill to ensure free
flow of air when the engine is operating.
•
Do not remove thermostat as it will affect
engine performance.
•
Do ensure proper tension of fan belt.
Deflection should not be more than (10
mm) when pressure is applied between
the fan pulley and the crankshaft pulley.
•
Do not run the belt tight as it will lead to
premature failure of water pimp and
alternator bearing.
•
Do not run the tractor when the radiator
hoses are leaking as it will lead to
overheating of the engine.
•
Do not run the belt loose as it will lead to
inefficient cooling and improper charging of
the battery.
Summary of Contents for 263-4WD-8G-STAGE-V
