-5-
Service
The
TD93-NYDOT
uses state-of-the-art light Emitting Diode (LED)
technology. These lightsticks are comprised of eight segments of Ultra-Bright
LEDs that are operated in a multiplexed mode to efficiently produce light
output with lifetimes up to 100,000 hours. Under normal circumstances, you
will not need to replace any lights in these lightsticks.
Head Replacement
If there is a failure in one of the arrays, the array
can easily be replaced without removing the
lightstick from the vehicle. The replacement head
is a part #TD93DLXTRH-* (*=color).
TD77-NYDOT-2 Controller
The TD77-NYDOT-2 controller contains two ATO "blade-type" fuses located in the back of
the controller. The fuses are accessible from the rear of the controller. The 20 amp fuse
controls power to the bar light assembly, while the 5 amp fuse powers the controller. If the
20-amp fuse blows the controller will continue to function normally, however, the roof
lamps will not. It is important to note that under normal circumstances the only reason a
fuse will blow is because there is a fault in the system.
If a fuse blows repeatedly it is a
signal that something is wrong.
Do not replace a blown fuse with anything other than
the same amperage rating as marked on the rear panel of the controller; doing so may
damage the unit, or worse yet start a fire. Likely causes of blown fuses are improper
wiring, harness damage, and/or improper bulb type.
If you have any questions concerning this or any other product, please contact our
Customer Service Department
at (585) 226-9787.
If a product must be returned for any reason, please contact our Customer Service
Department to obtain a Returned Materials Authorization number (RMA #) before you ship
the product back. Please write the RMA # clearly on the package near the mailing label.
LED FIVE YEAR LIMITED WARRANTY
The manufacturer warrants this LED light against factory defects in material and
workmanship for five years after the date of purchase. The owner will be responsible for
returning to the Service Center any defective item(s) with the transportation costs
prepaid. The manufacturer will, without charge, repair or replace
at its option
,
products, or part(s), which its inspection determines to be defective. Repaired or
replacement item(s) will be returned to the purchaser with transportation costs prepaid
from the service point. A copy of the purchaser's receipt must be returned with the
defective item(s) in order to qualify for the warranty coverage. Exclusions from this
warranty include, but are not limited to, domes, and/or the finish. This warranty shall not
apply to any light, which has been altered, such that in the manufacturer's judgment,
the performance or reliability has been affected, or if any damage has resulted from
abnormal use or service.
There are no warranties expressed or implied (including any warranty of merchantability
or fitness), which extend this warranty period.
The loss of use of the product, loss of time,
inconvenience, commercial loss or consequential damages, including costs of any
labor, are not covered
. The manufacturer reserves the right to change the design of
the product without assuming any obligation to modify any product previously
manufactured.
This warranty gives you specific legal rights. You might also have additional rights that
may vary from state to state. Some states do not allow limitations on how long an
implied warranty lasts. Some states do not allow the exclusion or limitation of incidental
or consequential damages. Therefore, the above limitation(s) or exclusion(s) may not
apply to you.
Summary of Contents for TD93-NYDOT
Page 8: ......
