2
CONTENTS
INTRODUCTION/WARRANTY ..........................................2
PUMP PERFORMANCE .......................................................3
MAJOR COMPONENTS ......................................................3
INSTALLATION ................................................................4-5
ELECTRICAL.....................................................................5-6
OPERATION........................................................................7
MAINTENANCE ...............................................................7-9
HELPFUL HINTS ...............................................................10
TROUBLESHOOTING GUIDE...........................................11
REPAIR PARTS .............................................................12-14
INTRODUCTION
Please read our instructions before installing and using your
Shallow Well Water System. This will help you obtain the
full benefits of the quality and convenience built into this
equipment. It will also help you avoid any needless service
expense resulting from causes beyond our control which are
not covered by our warranty.
Carefully read and follow all safety instructions in this
manual or on pump.
This is the safety alert symbol.
When you see this
symbol on your pump or in this manual, look for one
of the following signal words and be alert to the potential
for personal injury!
warns about hazards that
will
cause serious
personal injury, death or major property damage if ignored.
warns about hazards that
will
or
can
cause se-
rious personal injury, death or major property damage if ig-
nored.
warns about hazards that
will
or
can
cause
minor personal injury or property damage if ignored.
The word
NOTICE
indicates special instructions which are
important but not related to hazards.
Never run pump dry. Running pump without
water may cause pump to overheat, damaging seal and pos-
sibly causing burns to persons handling pump. Fill pump
with water before starting.
Never run pump against closed discharge.
To do so can boil water inside pump, causing hazardous
pressure in unit, risk of explosion and possibly scalding
persons handling pump.
Motor normally operates at high temperature
and will be too hot to touch. It is protected from heat dam-
age during operation by an automatic internal cutoff switch.
Before handling pump or motor, stop motor and allow to
cool for 20 minutes.
1. To avoid risk of serious bodily injury and property dam-
age, read safety instructions carefully before installing
pump.
2. Follow local and/or national plumbing and electrical
codes when installing pump.
3. Keep well covered while installing pump to prevent
leaves and other debris from falling into well, con-
taminating well and possibly damaging pump.
4. Protect pump and piping system from freezing. Allowing
pump or water system to freeze could severely damage
pump and voids warranty.
To avoid serious injury and equip-
ment damage, limit system pressure to 100 pounds
per square inch (PSI) or below at all times. Over-
pressure can cause tank blowup; install relief valve
capable of passing full pump volume at 100 PSI.
5. With a new well, test well for purity before use. Consult
local Health Department for procedure.
Hazardous voltage. Can shock, burn,
cause death, or start fires.
FULL ONE YEAR WARRANTY ON CRAFTSMAN
®
WELL PUMP
For one year from the date of purchase, Sears will repair or replace well pump, free of charge, if defective in material or workmanship.
LIMITED WARRANTY ON CRAFTSMAN
®
PROFESSIONAL HYDRO-GLASS
®
WELL PUMP
After one year and through three years from the date of purchase, Sears will furnish, free of charge, a replacement part for any defective part. You pay labor.
FULL FIVE YEAR WARRANTY ON CRAFTSMAN
®
CAPTIVE AIR TANK
For five years from date of purchase, Sears will repair or replace the tank, free of charge, if defective in material or workmanship.
This warranty does not cover repairs or replacement parts necessary because of abuse or negligence, including failure to install, adjust and operate this pump
according to the instructions in the owners manual.
LIMITATION OF LIABILITY
SEARS WILL NOT BE LIABLE FOR LOSS OR DAMAGE TO PROPERTY OR ANY INCIDENTAL OR CONSEQUENTIAL LOSS OR EXPENSE FROM PROPERTY
DAMAGE DUE DIRECTLY OR INDIRECTLY FROM THE USE OF THIS PRODUCT.
Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you.
WARRANTY SERVICE IS AVAILABLE BY SIMPLY CONTACTING THE NEAREST SEARS SERVICE CENTER/DEPARTMENT IN THE UNITED STATES.
This warranty applies only while this product is in the United States.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
Sears, Roebuck and Co., Dept. 817WA, Hoffman Estates, IL 60179
READ AND FOLLOW SAFETY INSTRUCTIONS!
Summary of Contents for CRAFTSMAN 390.252157
Page 15: ...15...
