52 Sedan Bridge
(525 Sedan Bridge)
3.10
S
ECTION
3 • U
SING
Y
OUR
B
OAT
17. C
ABLEMASTER
TM
W
ITH
R
EMOTE
(A
UTOMATIC
S
HORE
P
OWER
C
ORD
A
DVANCE
/R
ETRIEVE
S
YSTEM
)
Your Sea Ray
®
is equipped with the Cablemaster
TM
shore power cord system located on the transom.
The system will advance and retrieve the shore
power cord as needed to hook up the shore power
system. The Cablemaster
TM
circuit breaker is
located on the main DC breaker panel on the
forward engine room bulkhead.
16. S
TEERING
S
YSTEM
The hydraulic power steering system (Figure
3.10.1) uses the boat's engines to provide the
“power” for the steering system, via a mechanical
or electrical motor driven hydraulic pump.
A manual hydraulic steering system, consisting
of a helm and a hydraulic cylinder (fitted with an
integral servo cylinder and a power steering
valve), supplies the “control” por tion of the
steering system.
Under normal conditions, with engines running, a
hydraulic oil supply is in a standby mode, ready
to be directed to the steering cylinder as dictated
by the steering wheel, servo cylinder and power
steering valve. Turning the steering wheel left or
right makes the system go from “standby” into
“operating” mode and move the steering cylinder
accordingly.
T
YPICAL
H
YDRAULIC
P
OWER
S
TEERING
A
SSEMBLY
(F
IG
. 3.10.1)
15. S
TOPPING
THE
G
ENERATOR
1.
Prior to generator shut
down turn OFF all AC
equipment and breakers
including main breakers
and allow the generator to
run a few minutes to cool
down. If desired, transfer
to shore power.
2.
Stop the generator by
pressing the bottom of
both generator switches or
pressing the stop switch
on the generator.
REFER TO OWNER’S MANUAL PACKET FOR
INSTRUCTIONS AND WARRANTY INFORMATION.
POWER
POWER
MAIN DISTRIBUTION PANEL
STOVE
ACCESSORY
AIR CONDITIONER
PUMP & RELAY
FWD AIR
CONDITIONER
SALON AIR
CONDITIONER #1
240 VOLT AC
GALLEY SYSTEMS
PORT SYSTEMS
BATTERY CHARGER
BOW THRUSTER
BATTERY CHARGER
ACCESSORY
ACCESSORY
120 VOLTS AC
AC VOLTS
0
10
30
20
50
AC AMPERES
GENERATOR
SHORE
0
100
200
300
40
AC VOLTS
0
100
200
300
SALON AIR
CONDITIONER #2
ACCESSORY
WATER HEATER
AFT AIR
CONDITIONER
BRIDGE/COCKPIT
AIR CONDITIONER
STBD SYSTEMS
AFT SYSTEMS
MICROWAVE
REFRIGERATOR/
FREEZER
WASHER/DRYER
ACCESSORY
GENERATOR
SHORE
PRIOR TO CONNECTING OR DISCONNECTING SHORE
POWER CABLE, TURN OFF PANEL MAIN BREAKER
AND BREAKER AT DOCKSIDE RECEPTACLE OR
SHORE POWER CABLE MAY BE DAMAGED.
GENERATOR
START/PREHEAT
STOP/ PRIME
ON
PREHEAT/
STATUS
RUN
SEE OWNERS MANUAL FOR
OPERATING INSTRUCTIONS
In the event of a power source failure, hydraulic
oil from the steering helm is automatically diverted
into the servo and steering cylinder, providing the
helmsman with manual backup steering.
An engine room mounted oil reservoir allows easy
fill and assists the in-line cooler in cooling the
hydraulic oil. An in-line oil filter helps to protect the
steering system components against contaminants.
REFER TO OWNER’S MANUAL PACKET FOR
INSTRUCTIONS AND WARRANTY INFORMATION.
D
C
B
STEERING CYLINDER
PUMP
OIL RESERVOIR
A
E
F
C
B
A
D
E
F
HELM
OIL COOLER
OIL FILTER