80
|
City Series CV72EPV
installation
919-821
08.16.18
2
CITY SERIES
17. Reinstall pilot cap and pilot retainer clip.
18. Prior to installing burner—adjust aerations settings - to 3/8" for LP. Re-
install burner (see Step 11).
19. Ensure the pilot light is in the correct orientation to the Burner. Recon-
nect the gas and electrical supply to the appliance. Start the appliance.
(see section on Lighting Instructions) Ensure that pilot and burner igni-
tion is completed without delay. Check both your inlet and outlet pres-
sures at full load. With a soapy solution, leak test the entire system.
Verify both the correct fl ame and pilot appearance.
20. See Gas Pipe Pressure Testing in manual.
15. Remove pilot retainer clip with pliers and pull off the pilot cap to expose
the pilot orifi ce.
16. Unscrew the pilot orifi ce with the Allen key; then replace with the LPG
pilot orifi ce and the pilot cap, provided in the kit.
Installer Notice:
These instructions must be left
with the appliance
.
Pilot retainer clip
14. Remove burner orifi ce with a 3/8" wrench. Use another wrench to hold
on to the elbow behind the orifi ce. Discard orifi ce. Reinstall new burner
orifi ce LPG stamped #47 and tighten.
WRROWLS
Burner Orifi ce
Location
13. Loosen 8 screws in locations shown below (2 at front and 2 at rear)—slide
burner to the left away from the orifi ce and lift out.
12. Bend the arm of the aeration lever bracket up from 90° to straighten and
release aeration lever (lever will come with the burner).
Burner screw locations
Slide burner to the left and lift out
City Series
NG SYSTEM DATA
Min. Supply Pressure
11" WC (2.73kpa)
Manifold Pressure - High
10" WC (2.49 kpa)
Manifold Pressure - Low
6.4" WC (1.59 kpa)
Orifi ce Size
#47 DMS
Maximum Input
45,500 Btu/h (13.33 kW)
Minimum Input
36,000 Btu/h (10.55 kW)
Altitude
0-4500 ft (0-1372m)
WRROWLS
WRROWLS
Aeration
lever
Bracket
CV72E shown
CV72E shown
CV72E shown
Summary of Contents for City CV72E Series
Page 113: ...City Series CV72EPV 113 notes ...
Page 118: ...118 City Series CV72EPV warranty ...
Page 119: ......