QGarden QG40-145SP, Instruction Manual

Page: 20 / 36

MAINTENANCE & STORAGE
WARNING
Improper maintenance & storage of the machine may void your warranty. Keep the machine
clean for better and safer performance.
Turn off the engine before performing any maintenance. If the engine must be run, make sure
the area is well ventilated. The exhaust emits dangerous carbon monoxide gases.
MAINTENANCE
Use only original equipment replacement parts. Other parts may not perform as well, may
damage the unit and may result in injury. In addition, use of other parts may invalidate your
warranty.
• Before each use, check all nuts & bolts to be sure they are sufficiently tightened.
• We recommend only manufacturer original parts are used when maintaining this
machine. Failure to do so could invalidate your manufacturer’s warranty.
• The engine must be switched off, with the spark plug cap removed, before the machine
is unassembled, cleaned, serviced or maintained.
SPARK PLUG
• Use only original replacement spark plug. For best results, replace the spark plug every
100 hours of use.
• Do not attempt to remove the plug from a hot engine in order to avoid possible damage
to the threads.
• Clean or replace the plug if fouled with heavy oily deposits. Recommended gap of the
spark plug electrode is 0.70-0.80mm.
• Replace the plug if the center electrode is worn or rounded at the end.
LUBRICATION
• WHEELS - Lubricate the ball bearings in each wheel at least once a season with a light oil.
ENGINE OIL CHANGE
CAUTION
Used oil is a hazardous waste product and must be disposed of properly. Do not discard with
household waste. Check with your local authorities, service center, or dealer for safe
disposal/recycling facilities.
Drain the oil while the engine is still warm to assure rapid and complete drainage
• Remove the dipstick.
• Please an approved container below the oil drain plug.
• Remove the Oil drain plug and allow oil to the drain into the approved container.
• Install Oil drain plug and wrench tighten.
• Refill with the recommended oil and check its level as required.
Oil capacity: See Specification section of this manual.
Wash your hands with soap and water after touching used oil.
NOTE:
Please dispose of used motor oil in a manner that is compatible with the environment. We
suggest you put it in a sealed container to your local service for reclamation. Do not throw it
away into the refuge collection or pour it on the ground or in drains.