Transactive Xtra User Manual
Page
19
of
40
Part No. 999015 / Rev.2 / Nov 2017
9.
Charging the hoist
The charger for the hoist is mounted in the end of the track. The charger would
have been installed at the same time as the track and hoist were installed.
The batteries should be charged on a regular basis. It is recommended
that the hoist be left on charge when not in operation, and at the end of
each day. This will maximise the life cycle of the batteries.
The hoist may remain connected to the charger indefinitely since the
hoist has a built-in regulator, eliminating the danger of overcharging.
To charge the hoist it is a simple matter of moving the hoist to the end of
the track where the charger is located. Refer to previously outlined
sections on how to move the hoist along the track. As a general rule it is
recommended that the carry bar be raised to a height so that it will not
interfere / hit anything or anyone.
For manually traversing hoists use caution when parking the hoist into the
charger. A slow speed should be used when close to the end of the track
where the charger is located.
The light will turn ORANGE on the hoist control panel and a slow beeping audible
alarm will sound if the batteries are low and require charging. The display screen
will also indicate low battery. Complete the transfer that is in progress and then
move hoist to the end of the track where the charger is located.
Following the ORANGE indicator, the light will turn RED on the hoist
control panel and a fast beeping audible alarm will sound indicating the
batteries are fully discharged and require charging. The display screen
will also indicate low battery. When the battery is discharged the UP
function will be disabled. The DOWN and EMERGENCY DOWN function
along with H - TRAVERSING will continue to operate
When the hoist is connected to the charger and turned ON, the indicator light
on the hoist will FLASH ORANGE. Once the hoist is turned OFF the indicator
light will change to a solid ORANGE. This indicates
that the hoist is on charge. After one hour, the hoist
may be used, however, overnight charging is
recommended. The EMERGENCY DOWN function
along with H - TRAVERSING will continue to operate.
(fig 8a.) Underside of hoist showing RED discharged battery indicator light
ON. A fast beeping will be sounded. When the hoist is connected to the
charger this light will be ORANGE indicating that the batteries are charging.
Use only the charger that was supplied with the hoist. Use of any other
charger will void all warranties and may cause damage to the hoist
Summary of Contents for Transactive Xtra
