Polaris R09VA17AA, Service Manual

Page: 26 / 187

2.16
MAINTENANCE
Fuel Valve Location
The fuel valve is located on the passenger side of the vehicle
below the gas cap. Always turn off the fuel when the vehicle is
not in use
Carburetor Draining
The carburetor float bowl should be drained before extended
periods of storage, or periodically to remove accumulated
moisture or sediment from the bowl.
1. Turn fuel valve to the ‘OFF’ position.
2. Place a container beneath the bowl drain hose.
3. Loosen drain screw and allow fuel in the float bowl and fuel
line to drain completely.
4. Tighten drain screw.
5. Turn fuel valve to “ON” and check for fuel leaks.
6. Start engine and re–check for leaks.
Fuel Pump / Fuel Lines
NOTE: Thoroughly clean the exterior of all fuel
related components before servicing.
The RZR170 fuel pump is located in the right rear wheel well.
1. Check the fuel lines for signs of wear, deterioration,
damage or leakage. Replace if necessary.
2. Be sure fuel line is routed properly.
IMPORTANT: Make sure line is not kinked or pinched.
3. Replace fuel lines every two years.
NOTE: For all other information related to the fuel
System, refer to Chapter 4.
Turn knob to operate
the fuel valve
Drain Screw
Open
Close
PartShark.com
877-999-5686